Pall Corporation certifies the specified product meets all manufacturing specifications and criteria for release.
Pall ® : MEMBRANE DISC FILTERS
Part Number: 66191 Membrane Type: GN-6 Metricel Physical Tests ® We verified the (Hydrophilic mixed Cellulose Esters) Criteria Specification Results Pore Size: 0.45 µm Depending on Lot Number: T71454 P/N: Expiration Date: September/2020 Thickness 114.3 - 190.5 µm Conform (4.5 - 7.5 mils) Product Description Diameter 47 mm Conform Pall Laboratory microbiology hydrophilic membranes Bubble Point Minimum of 1.8 Conform are available as single packed membranes or as 200 bar membranes for use with Sentino® Filter Dispenser. (180 kPa, 1.8 psi) Both configurations are optimal for microbiological in water testing as membrane filtration is the method of choice for testing. The dotted gridlines provide guidance for Water Flow Rate 65 mL/min/cm² Conform qualification of bacterial or fungal colonies without at 0.7 bar (70 kPa, growth inhibition or enhancement. 65 psi) Wet Time 15 seconds Conform Materials of Construction Biological Tests Growth Recovery Filter Media: GN-6 Metricel (Hydrophilic mixed The membranes demonstrate typical recovery of the Cellulose Esters) target microorganism listed below as directed per ISO 7704 and Standard Methods for the Examiniation of Gamma Irradiation Information Water and Wastewater. All S-pack membranes and Sentino Dispenser Pack Microorganism Specification - Results Refills are gamma irradiated with a maximum dosage of Acceptable 30 kGys. A Quarterly Dose Audit is conducted to growth demonstrate continued effectiveness of the dose Bacterial 90% batch Complies delivered as required in ANSI/AAMI/ISO 11137-2. Recovery average of E. coli ATCC 11229 on Quality Assurance Lot Release Criteria mFC and This product is tested and monitored for compliance to mENDO ISO 7704 and Standard Methods for the Examination of microbiological Water and Wastewater with the following characteristics: media In addition to the above tests, this product met manufacturing inspection standards and requirements for full traceability by the lot number. This product was manufactured in a Pall facility under a Quality Management System and Environmental Management program approved by an accredited registering body to ISO 9001 and ISO 14001, respectively. Consider only unopened, undamaged packages for use. Further information is available by contacting Pall. 13/September/2017
James Merrill, Quality Manager, Pall Pensacola Date of Manufacture