Professional Documents
Culture Documents
Kyocera Manual
Kyocera Manual
Kyocera Manual
(Page.1/13)
There might be the possibility that the boss section A, B of the cassette right guide (No.1) gets whitened or
broken. Therefore, the shape of the boss section A, B is changed. If the boss section A, B are broken, the bottom
plate does not go up at the primary feeding and there might be the possibility to occur service call error C1010
(Lift motor error).
[The cassette right guide (No.1) is viewed from the right side of the machine main body]
X
Front side of Back side of
the machine the machine
Field Measure: When the above phenomenon occurs, replace the cassette right guide (No.1) and upgrade
the engine firmware to newest version.
N00096045 (Q1311004)/N00097926; SC1010; C1010
(Page.2/13)
Parts Table
Replacement procedure
Power cord
connector
cover Rear cover
[Detaching the rear left cover]
1) Release the hook while pulling it to the front side
2) Detach the rear left cover
2
Hook
Rear left
cover
Upper cover
FFC
Assy
Connector
(Page.3/13)
5
Screw
Screw Screw
Left cover
7
Waste toner
box cover
(Page.4/13)
Screw
Left lower cover
10 [Removing the rear cover]
1) Remove the screw and remove the grounding wire Grounding wire Screw
2) Open the connector cover and disconnect 3 connectors
Connector
Rear cover
Connector cover
3) Slide the rear cover to detach the fulcrum shaft while
retracting it Fulcrum shaft
(Rear cover Assy)
Screw
Connector Connector
cover A
60 東京
A B C
名古屋
40
大阪
20 (Page.5/13)
Connector cover B
11
Connector
(Page.6/13)
Lock lever
2) Pull out the developer unit
3) Release the hook and sliding the container guide to Container guide Hook
detach
Upper cover
12
Hook
(Page.7/13)
(Note)
Do not remove/install the main PWB Assy while the power
13 is on. If the main PWB Assy is removed/installed while the
power is on, there is a danger to damage the machine or
the main PWB.
Screw
FFC Wire
Screw
Controller
box cover
[Removing the power supply PWB] (Continue)
Grounding wire
6) Remove 3 screws and disconnect 13P connector, and Power supply
remove the power supply PWB PWB Assy
Screw
14
13P
connector
ビス
(Page.8/13)
15
Screw
* If removing only the bottom plate, loosen 2 screws at the
right frame is OK to work with tough, in order to remove the Screw
cassette right guide in the following process, it is necessary 底板
Bottom plate 2
16 to remove the screw at the right frame side 2
Screw
Screw
(loosen)
Connector
(Page.9/13)
Joint
Screw section
17
Screw
Duplex Assy
Feed roller shaft
18 [Remove the cassette right guide] Screw
1) Disconnect 4P connector, 2P connector, 12P connector 2P
2) Release 4 positions of hooks and remove one screw to connector
remove the cassette right guide attached to the inside 4P
of the machine right frame connector 12P
connector
Hook
(Page.10/13)
(Note)
When removing, if the spring comes off from the inside
(frame side) of the cassette right guide, attach it.
Reattach/reconnect all the parts, connectors, FFC to the
20
original position by the procedure the above
(Page.11/13)
(Page.12/13)
(Page.13/13)