This document summarizes the process of selecting a thread schedule for a pipe with an internal diameter of 12 inches and wall thickness of 10.31 mm. It provides the thread depth and number of threads per inch based on standards. It then calculates the basic thickness, allowance thickness, and rated thickness to check if the selected Schedule 40 pipe satisfies the minimum rated thickness requirement with an excess of 2.54 mm.
This document summarizes the process of selecting a thread schedule for a pipe with an internal diameter of 12 inches and wall thickness of 10.31 mm. It provides the thread depth and number of threads per inch based on standards. It then calculates the basic thickness, allowance thickness, and rated thickness to check if the selected Schedule 40 pipe satisfies the minimum rated thickness requirement with an excess of 2.54 mm.
This document summarizes the process of selecting a thread schedule for a pipe with an internal diameter of 12 inches and wall thickness of 10.31 mm. It provides the thread depth and number of threads per inch based on standards. It then calculates the basic thickness, allowance thickness, and rated thickness to check if the selected Schedule 40 pipe satisfies the minimum rated thickness requirement with an excess of 2.54 mm.
Thread = Yes For a.- Nominal thickness dn = 12 in tnom = 10,31 mm Note 7 When thread is to be considered, the number of NT = 8 threads/inch (Note 8) threads per inch is obtained from Table 2 and the TD = 2,75 mm (Nota 9) thread heigh from Table 1 of sheet 6. b.- Worst case of nominal thickness 8.- Allowances (Over Thickness) tnom:WC = tnom * 0.875 tallowances = TC + TD tnom = 10,31 mm Note 8 Table 2, ASME B1.20.1-1983, gives the number of TC = 1,59 mm tnom.WC = 9,02 mm threads per inch TD = 2,75 mm tallowances = 4,34 mm c.- Basic thickness Note 9 For a number of threads per inch NT, Table 1, tbasic = 2,15 mm ASME B1.20.1-198 gives a thread depth TD 9.- Schedule selected (Note 10) Sch = 40 d.- Basic and Allowances thickness Note 10 Select a shedule, that with the used nominal tbasicAll = tbasic + tAllowances diameter, will satisfy the requirements. 10.- Nominal thickness tbasic = 2,15 mm tnom = Pipe_Imp_CS_Thickness_dn_sch tallowances = 4,34 mm dn = 12 in tbasicAll = 6,49 mm Sch = 40 tnom = 10,31 mm e.- Requisite 11.‐ Rated thickness tnom.WC >= tBasicAll trated = tnom * 0.875 - tAllowances tnom.WC = 9,02 mm tNom = 10,31 mm tbasicAll = 6,49 mm tallowances = 4,34 mm Selected shedule is correct trated = 4,68 mm t = 2,54 mm 12.- Requisite trated >= tBasic trated = 4,68 mm tBasic = 2,15 mm Selected shedule is correct