Professional Documents
Culture Documents
Areva SF6 Circuit Breaker - Intervention On The FK3 - 4 Operating Device
Areva SF6 Circuit Breaker - Intervention On The FK3 - 4 Operating Device
Areva SF6 Circuit Breaker - Intervention On The FK3 - 4 Operating Device
Presentation
Topic Page
Positions of optical signalization 2
Safety measures 3
Preparing the operating device 4
Replacing an opening or closing electro--magnet 5
Resumption of service 6
Lubrication 8
Cleaning the windows 9
06--2004 L51--303EN/03
E AREVA 1/10
Maintenance
Intervention on the FK3-- 4 operating device
A position
B position
C position
D position
06--2004 L51--303EN/03
E AREVA 2/10
Maintenance
Intervention on the FK3-- 4 operating device
Safety measures
Circuit--breaker The table below gives the steps to prepare the circuit--breaker to work safely :
general preparing
Release the springs The table below gives the procedure to release the closing spring and the
opening spring depending the circuit--breaker state :
If the circuit--breaker
Action
position is ...
In the operating device, activate the
opening handle and the closing han-
dle like below :
Closed 1 -- Open
2 -- Close
3 -- Open
Check the optical Check that the operating mechanisms optical signalization shows the sym-
signalization bols below :
06--2004 L51--303EN/03
E AREVA 3/10
Maintenance
Intervention on the FK3-- 4 operating device
Introduction In order to perform certain maintenance operations inside the operating de-
vice it is necessary to remove some cabinet parts.
Removing The table below gives the steps of side panels removing :
side panels
2
x2
M8 3
2 Take hold of the left side
panel (3) from underneath, 3
pull slightly towards the out-
side, then downwards to re-
move it.
06--2004 L51--303EN/03
E AREVA 4/10
Maintenance
Intervention on the FK3-- 4 operating device
Process The table below gives the steps of replacing an opening or closing electro--
magnet :
9
5 Reinstall the core (11).
06--2004 L51--303EN/03
E AREVA 5/10
Maintenance
Intervention on the FK3-- 4 operating device
Resumption of service
Installing the side Insert the side panel (3) under the edge of the roof plate (4). Press it down to
panels insert the mounting screws and fasten using nuts (2).
4
x2
2
M8
06--2004 L51--303EN/03
E AREVA 6/10
Maintenance
Intervention on the FK3-- 4 operating device
Energizing The table below gives the resumption of service steps of the circuit--breaker
pole :
Check the optical Check that the operating mechanisms optical signalization shows the sym-
signalization bols below :
06--2004 L51--303EN/03
E AREVA 7/10
Maintenance
Intervention on the FK3-- 4 operating device
Lubrication
Principle No future lubrication will be necessary. The bearings and rollers have been
lubricated in our workshops with special grease :
ASEOL SYLITEA 4--018
This grease can easily endure very low temperatures and has an excellent
resistance to ageing. So that its qualities are not modified during use, it is pro-
hibited to :
Mixture with other lubricants can cause the layer of grease to become too
hard.
06--2004 L51--303EN/03
E AREVA 8/10
Maintenance
Intervention on the FK3-- 4 operating device
06--2004 L51--303EN/03
E AREVA 9/10
Maintenance
Intervention on the FK3-- 4 operating device
06--2004 L51--303EN/03
E AREVA 10/10