Professional Documents
Culture Documents
CV338H-B32 (Haier 32A6S)
CV338H-B32 (Haier 32A6S)
Today to share with you this motherboard is a new Haier motherboard, the failure rate is high, most of the problems for the card LOGO or
boot gray screen, manufacturers provide mandatory upgrade package, only to solve part of the U disk upgrade is still invalid , Temporarily
unable to find a solution.
iFix received the demand, began to prepare solutions, by Wei Cai Wu provided two motherboards, one of the good board, a bad board, good
data back from the good board, write bad board, the perfect boot, all functions are normal . Just follow the running process.
Motherboard parameters as follows:
In accordance with the point map welding ISP line, CLK (white), CMD (purple), D0 (green), ground (black), and then short circuit the two
ends of the crystal, as shown below:
Open the RT809H user interface, enter EMMC in the print box, pop-up small category select "EMMC_AUTO_ISP", as shown below:
Point settings, pop-up small box set in accordance with the thumbnail, as shown below:
Point to write, select the backup file in the pop-up file path, double-click any one to start writing, as shown below:
About less than 10 minutes, 4G backup file is written successfully, as shown below:
Next, verify that the motherboard serial port location in the J45 at the 4PIN socket, corresponding with a good RX, TX, GND to the
programmer's ISP port, you can view the print.
At this time we should pay attention to the bottom of the parameters set, select a good point after a certain point to save (because at
this time have not switched from EMMC read and write to print view state), the line order is generally not the first two is the second
Kind, save, click "serial print."
Power on the motherboard, you can see the start-up process of printing information, as shown below:
Boot everything is normal.