Professional Documents
Culture Documents
Before Operation: Operation and Maintenance Manual Excerpt
Before Operation: Operation and Maintenance Manual Excerpt
® ®
© 2010 Caterpillar
All Rights Reserved
SEBU7426-06
April 2007
Operation and
Maintenance
Manual
325C Excavator
CRB1-Up (Machine)
JLC1-Up (Machine)
JLD1-Up (Machine)
CSJ1-Up (Machine)
100 SEBU7426-06
Operation Section
Before Operation
Operation Section
Before Operation
i01983975
Daily Inspection
SMCS Code: 1000; 6319; 6700; 7000
NOTICE
Accumulated grease and oil on a machine is a fire haz- g00101867
ard. Remove this debris with steam cleaning or high Illustration 55
pressure water, at least every 1000 hours or each time
any significant quantity of oil is spilled on a machine. Inspect the hydraulic system for leaks. Inspect the
hydraulic cylinders and inspect the cylinder rods and
seals for damage or for excessive wear. Inspect the
Perform the following procedures on a daily basis. linkage and the work tool for damage or for excessive
wear. Make any necessary repairs.
• Operation and Maintenance Manual, “Cooling
System Level - Check”
Refer to the Maintenance Section for the detailed Inspect the final drives for leaks. Make any necessary
procedures. Refer to the Maintenance Interval repairs. Check the oil level if you see leakage.
Schedule for a complete list of scheduled
maintenance. Inspect the swing drive for leaks. Make any
necessary repairs.
SEBU7426-06 101
Operation Section
Before Operation
i02415882
g00101987
Illustration 57
Inspect all of the belts for the engine attachments. Face the machine whenever you mount the machine
Replace any belts that are worn, frayed, or broken. and whenever you dismount the machine. Maintain a
three-point contact with the step and with handholds.
Make sure that all covers and guards are securely
attached. Inspect the covers and the guards for Note: Three-point contact can be two feet and one
damage. hand. Three-point contact can also be one foot and
two hands.
Inspect the steps, the walkways, and the handholds.
Clean the steps, the walkways, and the handholds. Do not mount a moving machine. Do not dismount a
Make any necessary repairs. moving machine. Never jump off the machine. Do
not try to mount the machine when you carry tools
Inspect the Falling Object Protective Structure for or supplies. Do not try to dismount the machine
damage. Tighten any loose bolts. If repairs are when you are carrying tools or supplies. Use a hand
needed, consult your Caterpillar dealer. line to pull equipment onto the platform. Do not
use any controls as handholds when you enter the
Inspect the operator compartment for trash buildup. operator compartment or when you exit the operator
Check for trash buildup under the floorplate. Keep compartment.
these areas clean.