Professional Documents
Culture Documents
SHD Series Introduction (0.7MB)
SHD Series Introduction (0.7MB)
SHD Series Introduction (0.7MB)
Energy saving
By directly monitoring the outlet air dew Switching time 2 min. 4 min. 6 min. 8 min. 10 min. 12 min. 14 min. 16 min. 18 min.
point, the switching time of adsorption and
regeneration can be variably controlled in
R
Desiccant cylinder
response to changes in the dew point.
Reduces the purge and achieves the
optimum energy-saving operation.
L
■ Normal operation Desiccant cylinder
About 13% reduction Desiccant cylinder switching time and purge reduction rate
Achieves 1/3 lower power
even in normal operation Switching time Purge reduction rate
consumption
2 min. 0%
Low noise
dB(A)
Rocket launch
No refrigerants used and
200
conforms to ISO 14001
180
Significantly reduces
Jet takeoff
160
120
110dB(A) Near by airplane engine
Car horn
The 2-stage exhaust system (PAT.P) achieves 100
Noise reduction
40
75dB(A)
When the noise is reduced by 10db, Sound of
20
human ears perceive the noise to be reduced by half leaves rustling
0
INDEX
Equipped as standard with a dew point sensor. The desiccant cylinder can be easily
As it digitally displays the pressure dew point, the removed by rotating it by 45°.
performance can be confirmed safely and reliably. Moreover, as the cylinder is locked
by a latch mechanism, the safety is excellent.
Precautions
Stainless steel tower adopted Air compressor can be connected directly
Non-corrosive stainless steel vessel is Refrigeration air dryer is not required on the inlet side.
used for the desiccant cylinder to Just one unit reliably maintains performance.
improve the supply air quality and reliability.
system list
Equipped as standard with
Dryer
filters in the inlet and outlet
AF2000 Series filters are equipped as standard on
both the inlet filter for maintaining the performance
of the heatless dryer and outlet filter for maintaining
Refrigeration
the quality of supply air. (Included)
dryer
Stainless steel AF4000 and AF5000 Series can be
optionally selected.
Desiccant
(2.5 to 24 m3/minANR) and 2 types of dew point sensors
dryer
(G: temperature / humidity sensor, M: dew point meter).
M type
membrane dryer
High polymer
Operability improved by the electronic control system
Pressure dew point digital display
Also displays dew point abnormalities, sensor abnormalities, etc.
1/3 to 1/2 (CKD conventional products comparison) Equipped as standard with remote operation/dew point sensor abnormality
output terminal, dew point abnormality output terminal dew point analog output
terminal. The operating status of the device can be centrally managed.
SHD 3000
You will be notified when it enters into energy-saving mode.
91