This document provides instructions for operating and constructing search coils for a Sniffer XR 71-DELTAPULSE metal detector. It describes the main functions of the detector including power, sense, threshold, signal, noise, fast zero, and low battery. It also notes the inclusion of two LEDs and a coil jack. Construction instructions are provided for making larger 1x4m coils or smaller 32-40cm coils using PVC pipes and copper or stranded cable for the windings. Parameters for small coils include a resistance of 3-5ohm and inductance of 400-500uh.
This document provides instructions for operating and constructing search coils for a Sniffer XR 71-DELTAPULSE metal detector. It describes the main functions of the detector including power, sense, threshold, signal, noise, fast zero, and low battery. It also notes the inclusion of two LEDs and a coil jack. Construction instructions are provided for making larger 1x4m coils or smaller 32-40cm coils using PVC pipes and copper or stranded cable for the windings. Parameters for small coils include a resistance of 3-5ohm and inductance of 400-500uh.
This document provides instructions for operating and constructing search coils for a Sniffer XR 71-DELTAPULSE metal detector. It describes the main functions of the detector including power, sense, threshold, signal, noise, fast zero, and low battery. It also notes the inclusion of two LEDs and a coil jack. Construction instructions are provided for making larger 1x4m coils or smaller 32-40cm coils using PVC pipes and copper or stranded cable for the windings. Parameters for small coils include a resistance of 3-5ohm and inductance of 400-500uh.
POWER– switches the detectors and regulates its power .
There are ten power levels – as it works mainly on 9 or 10 level. SENSE – regulates the power of gained signal. When the soil is normal it works mainly on level 10. THRESHOLD – a threshold tone. In dry soil it normally works on level 9 or 10. When the moisture is high it’s good to work under level 8. SIGNAL – eliminates soil mineralization. When soil is normal it’s good to work on level 8 to 10, while the soil is highly mineralized it’s recommended to work on level 0 to 3. NOISE – eliminates influence of Roman pottery over the apparatus, it’s used in combination with SIGNAL. FAST ZERO (TUNE)– press this button for about 2-3 seconds when the detector is ready to work with and the coil is over the ground. Pressing this button eliminates ground mineralization and the detector chooses itself the most suitable depth for searching. While press the button “fast zero” you must be sure there is no metal objects under the coil. We recommend press this button every 4-5 minutes. LOW BATTERY – if the light switches on while operating, it shows it’s necessary to charge the battery. If it happens, please, do not 2 LEDS COIL – a coil jack.
11. VOLUME-Adjust sound.
CONSTRUCTION of the search coil
1.Framework search coil can be made as are needed 4 x 1 m. pipe with
diameter 32 mm.4 count PVC elbow.Connect the four tubes in a square with knees.Inside this square have the coil windings. Windings of the coil can be made from standard Internet FTP cable CAT 5 or UTP 8 wire cable,by making a coil inside the pipe and can outside of pipes .Eight cables are connected in series ,as start and end are the terminals of the coil. Another option for making the framework as a coil inside the pipes are lap 15- 16 coils of flexible (stranded cable) with a diameter of 0.70 to 1 mm. 2.For the construction of a small coil, for example 32-40 cm are needed about 3 turns of FTP cable series.Or 25-30 windings from 0.5-0.8 mm . The coil parameters are:Resistance about 3-5om. And inductance about 400-500uh. . To further the scheme may include LCD for visual display of signal level and battery.