Professional Documents
Culture Documents
Shear and Diagonal Tension
Shear and Diagonal Tension
DIAGONAL TENSION
Prepared by:
CORPUZ, JOHN VIRGO E.
SHIRATO, YURIKA P.
SISON, BERNADETTE P.
TACORDA,ERIKA JOY T.
INTRODUCTION
The reinforced concrete beams are designed primarily for flexural strength and
shear strength. Beams are structural members used to carry loads primarily by internal
moments and shears. In the design of a reinforced concrete member, flexure is usually
considered first, leading to the size of the section and the arrangement of
reinforcement to provide the necessary resistance for moments.
For safety reasons, limits are placed on the amounts of flexural reinforcement to
ensure ductile type of failure. Beams are then designed for shear. Since shear failure is
frequently sudden with little or no advanced warning, the design for shear must ensure
that the shear strength for every member in the structure exceeds the flexural strength.
The shear failure mechanism varies depending upon the cross-sectional dimensions,
the geometry, the types of loading, and the properties of the member
INTRODUCTION
Beams must have an adequate safety
margin against other types of failure, some
of which may be more dangerous than
flexural failure. Shear failure of reinforced
concrete, more properly called “diagonal
tension failure” is one example.
A Shear crack may develop which is
inclined at 45° to the horizontal and it
develops at mid-depth near the support
grows towards the top and bottom. Shear
failure is brittle and, therefore must be
avoided. So Stirrups are provided to resist
such shearing action and also prevent
the longitudinal bars from bending
outward.
TYPES OF SHEAR FAILURE
Diagonal Tension Failure: This type of failure is caused
due to inadequate shear reinforcement. The diagonal
shear crack forms in the member at 45 deg. and
propagates rapidly causing failure.
1. Vertical Stirrups
2. Bent up bars along with stirrups
3. Inclined Stirrups
VERTICAL STIRRUPS
These are the steel bars vertically placed around the
tensile reinforcement at suitable spacing along the
length of the beam. Their diameter varies from 6
mm to 16 mm. The free ends of the stirrups are
anchored in the compression zone of the beam to
the anchor bars (hanger bar) or the compressive
reinforcement. Depending upon the magnitude of
the shear force to be resisted the vertical stirrups
It is desirable to use closely spaced stirrups for better
may be one legged, two legged, four legged and so prevention of the diagonal cracks. The spacing of stirrups
on as shown near the supports is less as compared to spacing near the
mid-span since shear force is maximum at the supports.
TYPES OF SHEAR REINFORCEMENT
INCLINED STIRRUPS
Inclined stirrups are also provided generally at 45ºº
for resisting diagonal tension as shown in Fig. 5.7..
They are provided throughout the length of the
beam.
BASIC CODE REQUIREMENTS
BASIC CODE REQUIREMENTS
BASIC CODE REQUIREMENTS
BASIC CODE REQUIREMENTS
BASIC CODE REQUIREMENTS
BASIC CODE REQUIREMENTS
BASIC CODE REQUIREMENTS
BASIC CODE REQUIREMENTS
BASIC CODE REQUIREMENTS
ILLUSTRATIVE PROBLEMS