Professional Documents
Culture Documents
Before Starting The Engine:: CAT 3512 B and C Series Maintenance
Before Starting The Engine:: CAT 3512 B and C Series Maintenance
- Walk around inspection for any type of leaks ( Fuel, Oil and Coolant).&
- Check all guards, all guards must be in their proper place.
- Ensure that the areas around the rotating parts are clear.
- Ensure that all clamps and connections are secure.
- Observe air cleaner service indicators must be in green area.
- Check level and inspect cooling system for leaks or loose connections.
- Inspect fan drive belts for cracks or deterioration.
- Inspect water pump for evidence of leaks.
- Inspect the fuel lines for loose fitting and leaks.
- Ensure that the fuel is supplied to the Engine.
- Check the oil dipstick for normal level.
- Operate the Engine at Low Idle for three to five minutes to allow the jacket water
temperature to begin rise before full RPM.
- Check all gauges during warm-up period.
- Make another walk around inspection.
- Check oil Pressure must be more than 19 psi to ensure that the two sequence valves
of jet cooling pistons are open.
1- Daily:
- Cooling system check level and temperature the nominal operating range is 88
to 100°C.
- Driven equipment inspect/ replace as required lubricate when the engine is
under load.
- Air cleaner differential pressure ,clean or replace when pressure become 19
inches of H2O.
- Oil differential pressure mustn’t exceed 15 psi.
- Fuel differential pressure mustn’t exceed 15psi.
- Oil level should be between add and full at the dipstick.
- Oil pressure at low idle rpm is 27 to 50 psi, at rated rpm is 40 to 87 psi.
- Normal fuel pressure is 50 to 75 psi.
- Maximum exhaust temperature is 575°C.
- Instrument panel check.
- Drain the air sediment tank.
- Walk around inspection.
- Walk around inspection for any type of leaks ( Fuel, Oil and Coolant).&
- Check all guards, all guards must be in their proper place.
- Ensure that the areas around the rotating parts are clear.
- Ensure that all clamps and connections are secure.
- Observe air cleaner service indicators must be in green area.
- Check level and inspect cooling system for leaks or loose connections.
- Inspect fan drive belts for cracks or deterioration.
- Inspect water pump for evidence of leaks.
- Inspect the fuel lines for loose fitting and leaks.
- Ensure that the fuel is supplied to the Engine.
- Check the oil dipstick for normal level.
- Operate the Engine at Low idle for three two five minutes, allow the jacket water
temperature to begin rise before load the engine.
- Inspect all parameters during warm-up period.
- Make another walk around and check for fluid leaks.
1- Daily:
- Inspect alternator.
- replace coolant temperature regulators.
- inspect crankshaft vibration damper.
- inspect engine mounts.
- Inspect/Clean the speed/timing sensor.
- Inspect starting motor.
- Inspect Turbocharger.
- Inspect Water pump.
JC70D Draw-works:
General inspections:
Daily maintenance: