Professional Documents
Culture Documents
I60O 150930 Trilithic CT 4 KK
I60O 150930 Trilithic CT 4 KK
Overview Consequently, readings taken from These leakage detectors all contain
The new CT-4™ is a 1U rack mounted the existing Seeker meter and the new special circuitry that is sensitive only to the
unit that is located in the head end that Seeker D meter produce similar results tagged signal from the CT-4 and rejects
provides an uncompromising tagging in the aeronautical band if the low band any signals that do not contain it.
solution for active analog or digital correlation of the Seeker D is set to
systems. analog. Warbling Identifier Tone
Searcher Plus, Searcher Plus GT, or
When several CATV systems operate Whether testing for leaks in both digital Super Plus analog leakage detectors
in the same area, it is often difficult to and analog systems, or monitoring generate an audible tone that varies in
determine which system is the source of aeronautical bands or LTE, the CT-4 used pitch with leak strength. A leak that has
a detected leak. The CT-4 is designed in conjunction with the Seeker D provides been tagged using the CT-2 or CT-3
to deal with the problem of leakage all of the capability to find and fix leaks operation mode of the CT-4 causes the
identification in dual cable or overbuilt quickly, accurately, and effectively. audible tone to “warble,” rising and falling
situations. in pitch at the rate of three oscillations per
Traditional Channel Tagging second. If the distinctive warbling sound is
Used as a system with Trilithic’s leakage The new CT-4 can also act as a traditional not detected, the operator can be sure that
receivers, the CT-4 eliminates all “false CT-2 or CT-3 analog tagger. When used
the leak did not originate in his system.
alarm” triggers and increase leak detection with legacy Trilithic leakage detectors,
sensitivity by four times over un-tagged this feature provides the ability to detect
Easy to Install
systems. tagged leaks and ignore untagged leaks,
The CT-4 is very simple to install where
saving time from false alarms from signals
RF signals reside. When being used in
Next-Gen Digital Tagging not originating in your system.
either the CT-4 or CT-3 operation modes,
The CT-4™ works in conjunction with the
The CT-4™ solves this problem by tagging the CT-4 is simply installed in a rack
new Seeker D™ Digital Leakage Detector
the system video carrier (CT-2 operation location near a combiner. Otherwise, the
to accurately detect and measure signal
mode) or an integrated carrier (CT-3 CT-4 can be used with any type modulator
leakage within the LTE and aeronautical
operation mode) with a low-frequency in the CT-2 operation mode by simply
frequency bands.
modulation. feeding the analog carrier through the
The Seeker D detects the proprietary CT-2 and then out to the combiner.
signal from the CT-4 with an unsurpassed With the tag function switched on, the
sensitivity of 2 to 2000 uV/m with Searcher Plus GT, Super Plus, Seeker
measurements that are scaled to an Lite, Seeker Lite², Seeker and Seeker SE
analog or QAM carrier of your choice. leakage detectors are immune to false
alarming.
Page 2 www.trilithic.com