Professional Documents
Culture Documents
ECU Reset
ECU Reset
Wait 3 seconds
After 7 seconds press and hold down accelerator pedel for 10 seconds...
Atfer 10 seconds the Engine Managment Light will start to flash, at this point remove foot from accelerator.
the Nav is now in diag mode, so let the EML flash for a bit. the press and hold the acclerator pedel down for
more than 10 seconds..this will then reset ECU and fuel pump etc......and put them into learning mode.
NOTE: When the EML light is flashing, this is listing possible fault codes... so if you know how to read the
fault codes or know the sequences then you can figure out any possible faults with your Nav with out getting
the dealer to do it!!