Professional Documents
Culture Documents
MSDS Gold Parawax X 6
MSDS Gold Parawax X 6
Gold Parawax X 6
GHS CLASSIFICATION
Acute toxicity : Not classified
Skin corrosion/irritation : Not classified
Severe eye damage/ eye irritation : Not classified
Respiratory or skin sensitization : Not classified
Germ cell mutagenicity : Not classified
Carcinogenicity : Not classified
Reproductive toxicity : Not classified
Specific target-organ systemic toxicity (single exposure, repeated exposure) : Not
classified
Aspiration hazards : Classification Not Possible
Hazardous to the aquatic environment : Category 3 (no symbol, no signal word)
HAZARD STATEMENTS
Harmful to aquatic life
PRECAUTIONARY STATEMENT
Avoid release to the environment
SYNONYMS : -
INGESTION
Rinse mouth out with water ensuring that mouthwash is not swallowed. Give about 250mL (2
glasses) of water to drink. DO NOT attempt to induce vomiting. Get medical attention.
EYE
Hold eyelids open and rinse the eye continuously with a gentle stream of clean running water
for at least fifteen minutes. Get medical attention.
SKIN
Remove contaminated clothing and wash thoroughly with soap and water. Use water alone, if soap
is unavailable. Apply a moisturizing hand cream, if available. Seek medical attention if any
soreness or inflammation of the skin persists or develops later. Launder affected clothing
before re-use.
INHALATION
Remove victim to fresh air and get medical attention, gold parawax has a low vapor pressure
and is not expected to present an inhalation.
PRE
ONS
SECTION 5 : FIRE FIGHTING MEASURES
R USE
PERSONAL PRECAUTIONS
Wear protective clothing and eliminate sources of ignition
ENVIRONMENTAL PRECAUTIONS
Prevent spills from entering sewers or drains
CONTROL PARAMETERS
Exposure Limit : Not available
PERSONAL PROTECTION
Safety goggles and polyvinyl chloride (PVC) gloves are sufficient for most applications.
If the product is being handled in such a way that repeated skin contact is likely to occur,
then overalls should also be worn.
CONDITIONS TO AVOID
Keep away from sunlight or ultraviolet light, heat sources, open flames and other source of
ignition
INCOMPATIBLE MATERIALS
Strong oxidizing agents such as liquid or powder chlorine
ACUTE TOXICITY :
Oral (LD50) : Not available
Dermal (LD50) : Not available
MOBILITY IN SOIL
Low range mobility in the soil.
ENVIRONMENTAL HAZARD
Marine Pollutant : Not available
REVISION INFORMATION
Revision Date : January 2, 2017
ABBREVIATIONS
GHS : Globally Harmonized System
CAS : Chemical Abstract Service
COC : Cleveland Open Cup
DISCLAIMER OF LIABILITY
The information contained in this SDS is obtained from sources which we believe are reliable.
However, the information is provided without any warranty, expressed or implied regarding its
correctness. This SDS was prepared and is to be used only for this product. If this product is
used as a component in another product, this SDS may not be applicable. Users should make
their own investigations to determine the suitability of the information for their particular
purposes.
The conditions or methods of handling, storage, use and disposal of the product are beyond our
control and may be beyond our knowledge. For this and other reasons, we do not assume
responsibility and expressly disclaim liability for loss, damage or expense arising out of or
in any way connected with handling, storage, use or disposal of the product.