Professional Documents
Culture Documents
Name Roll No. Section Submitted To: University of Engineering and Technology, KSK
Name Roll No. Section Submitted To: University of Engineering and Technology, KSK
Name Roll No. Section Submitted To: University of Engineering and Technology, KSK
: HIRA ARSHAD
NAME
: 2018-EE-295
ROLL NO.
: B
SECTION
: DR. FAROOQ MUKHTAR
SUBMITTED TO
OBJECTIVE:
To design and study the Non-Inverting Amplifier circuit.
OPERATIONAL AMPLIFIER:
PIN CONFIGURATION:
EQUIPMENT
Oscilloscope
Power Supply
Function Generator
Breadboard
PROCEDURE
1. The OP Amplifier is placed on the breadboard such that there is no short.
𝑅2
2. Two resistors are selected such that 1> < 3 and are placed on the breadboard
𝑅1
such that R1 connects with pin 2 of OP Amplifier, and R2 is connected with pin 2 and
pin 6 of OP amplifier.
3. Now for ground connect positive of one power supply with negative of other power supply
with wire. This is how the ground is created. Now connect the ground with the R1 using wire.
4. For input connect the wire from the positive terminal of power supply to the pin 3 of the OP
amplifier.
5. For output connect the negative of the other supply with pin 6 of OP amplifier using wire.
7. Now connect the negative terminals of signal generator and oscilloscope with the ground at
8. Connect positive red crocodile clips of oscilloscope with the output at pin 6 of OP amplifier.
𝑅2
value from the formula + 1.
𝑅1
CALCULATIONS:
R1 = 1K ohms
R2 = 1.2K ohms
𝑅2
+ 1 = 1.2 + 1 = 2.2
𝑅1