Professional Documents
Culture Documents
B.E - (2008 Patt.) - 1-5 PDF
B.E - (2008 Patt.) - 1-5 PDF
B.E - (2008 Patt.) - 1-5 PDF
SECTION - I
P.T.O.
Q3) A continuous beam ABC is loaded as shown in fig. 3. It has constant flexural
rigidity. Fixed support at A, roller support at B & guided support at C. Analyse
the beam using flexibility method. [16]
OR
Q4) Portal frame ABC is loaded as shown in fig. 4. It is subjected to udl 40 kN/m
over span AB. Draw BMD taking EI constant for AB & BC. Use flexibility
method for analysis. [16]
Q5) A pin jointed truss is as shown in figure 5. Analyse the truss by flexibility
method. [18]
OR
Q6) Analyse the beam AB, having internal hinge at C. Use stiffness method. EI is
uniform for all spans. Refer fig. 6. [18]
[4164]-409 2
SECTION - II
Q9) a) Using proper DOFs write stiffness matrix equation for a member of
orthogonal grid structure. [8]
b) Using structure approach develope stiffness matrix of grid structure as
shown in fig 9.b. Take E = 2 × 105 Mpa
I = 20 × 105 mm4, G = 0.8 × 105 Mpa
Ip = 50 × 105 mm4 for both members [8]
OR
[4164]-409 3
Q10)Analyse & draw BMD for grid structure as shown in fig 10. Use stiffness
method. [16]
zzz
[4164]-409 4
Total No. of Questions : 12] SEAT No. :
SECTION - I
Q1) a) Define following terms. [8]
i) Turbines
ii) Pumps
iii) Compressible Flow Machines
iv) Incompressible Flow Machines
b) Calculate the specific speeds in the following cases; [8]
i) A centrifugal compressor which develops a pressure ratio of 2 while
running at 24000 rpm and discharging 1.5 kg/s of air.
ii) An axial compressor stage requiring a power of 460 kW and
discharging 15 kg/s of air while running at 6000 rpm.
OR
Q2) a) Draw and explain performance curves for following: [8]
i) Characteristic curve for pump.
ii) Characteristic curve for compressor.
iii) Characteristic curve for axial fan.
iv) Characteristic curve for centrifugal fan.
b) Write equations of energy transfer between fluid and rotor. [6]
c) Define specific speed. What is its significance? [2]
P.T.O.