This document provides a checklist for preparing and operating the DJI Phantom 4 drone. It lists steps to take before leaving for a flight, including ensuring all components like the SD card, batteries, and tablet are prepared. It also lists pre-flight, takeoff, post-flight, and over water flight checklists to ensure safe operation and inspection of the drone.
This document provides a checklist for preparing and operating the DJI Phantom 4 drone. It lists steps to take before leaving for a flight, including ensuring all components like the SD card, batteries, and tablet are prepared. It also lists pre-flight, takeoff, post-flight, and over water flight checklists to ensure safe operation and inspection of the drone.
This document provides a checklist for preparing and operating the DJI Phantom 4 drone. It lists steps to take before leaving for a flight, including ensuring all components like the SD card, batteries, and tablet are prepared. It also lists pre-flight, takeoff, post-flight, and over water flight checklists to ensure safe operation and inspection of the drone.
l SD card installed in Phantom 4 l Verify in GPS mode l USB cable l Start motors and idle l Transmitter fully charged l Verify no warning messages l Batteries fully charged l Verify home point and altitude set l Tablet fully charged l Transmitter harness AFTER TAKEOFF l Extra props l Hover, verify systems OK l Tablet hood l Check flight contols l Camera filters
PRE-FLIGHT POST FLIGHT
l Remove gimbal lock l Turn off Phantom battery l Install battery, check secured l Turn off transmitter l Check hull/landing gear for defects l Install gimbal lock l Check props for cracks and defects l Remove props & inspect for damage l Install props and verify secured l All batteries are off before packing l Install tablet on transmitter l Check area for forgotten items l Open DJI Go app l Turn on Transmitter l Turn on Phantom 4 l Check warm up notifications l Battery voltage and percentage l Format SD card l Camera settings as needed l Camera lens filters installed a Over Water Flight a Check wind speed and direction a Disable VPS (if applicable) a Verify 10 GPS satellites minimum