API 570 2” Edition, Including Addenda 1, 2, & 3 Ballot 570-07-04 Final
May 17, 2004
Scorecard Item: 570-016
Title: Externally Applied Enclosures for Temporary Repairs
Date: September 15, 2003
Contact: Name: Kelly Smith
Company: ConocoPhillips
Phone: (680) 767-3776
E-mail: kj.smith@conocophillips.com
Purpose: Revise 8.1.4 to not exclude other types of nonwelded repairs that may currently exist or
are being used in industry
570-1-03/02
0
Current technologies, such as composite wraps are being used by operating companies
fn the basis of not being addressed in 570. By changing to the proposed language, the
constraints or requirements of 8.1.4 would be imposed on all nonwelded repairs,
Notes:
API 570, Section 8.1.4 — Nonwelding Repairs (On-Stream)
‘Temporary repairs of locally thinned sections or circumferential linear defects may be made
on-stream by installing a properly designed and fabrieated-bolted-lealc-elamp applied
enclosure (e.g. bolted clamp, nonmetallic composite wrap, metallic and epoxy wraps, or other
non-welded applied temporary repair. The design shall include control of axial thrust loads if
the piping component being elamped enclosed is (or may become) insufficient to control
pressure thrust. The effect of elamping enclosing (crushing) forces on the component also
shall be considered.
During tumarounds or other appropriate opportunities, temporary leak sealing and leak
dissipating devices, including valves, shall be removed and appropriate actions taken to
restore the original integrity of the piping system. The inspector and/or piping engineer shall
be involved in determining repair methods and procedures.
Procedures that include leak sealing fluids (“pumping”) for process piping should be
reviewed for acceptance by the inspector or piping engineer. The review should take into
consideration the compatibility of the sealant with the leaking material; the pumping pressure
on the clamp (especially when repumping) and any resulting crushing forces: and the risk of
sealant affecting downstream flow meters, relief valves, or machinery; the risk of subsequent
leakage at bolt threads causing corrosion or stress corrosion cracking of bolts; and the number
of times the seal area is repumped.
Page | of |