Professional Documents
Culture Documents
(VOLKSWAGEN) Manual de Taller Volkswagen Jetta 1999 2006 PDF
(VOLKSWAGEN) Manual de Taller Volkswagen Jetta 1999 2006 PDF
Multimeter .
Wiring diagram
Test procedure
Test requirement
All electrical consumers such as, lights and rear window defroster, switched off.
Vehicles with automatic transmission, shift selector lever into position "P" or "N" .
Note:
Use only gold-plated terminals when servicing the electrical harness connector
terminals in Closed Throttle Position (CTP) Switch F60 .
Test sequence
x-ebahn:///C:/Program%20Files/eBahn/data/VW-A-A4-FU11.ebn/VW/A/A4/Repair%20Ma... 8/7/2009
Closed Throttle Position Switch F60, Checking Page 2 of 4
Disconnect the Closed Throttle Position (CTP) Switch F60 6-pin electrical harness
connector .
Using a multimeter , check the Closed Throttle Position (CTP) Switch F60 electrical
harness connector terminals 4 to 6 for resistance.
Specified value: 0 Ω
Specified value: ∞Ω
Checking wiring
x-ebahn:///C:/Program%20Files/eBahn/data/VW-A-A4-FU11.ebn/VW/A/A4/Repair%20Ma... 8/7/2009
Closed Throttle Position Switch F60, Checking Page 3 of 4
Specified value: 1Ω
Check the wiring for a short circuit to each other, Battery (+), and Ground (GND).
Check the electrical harness connector for damage, corrosion, loose or broken
terminals.
Erase the DTC memory. Refer to Diagnostic Mode 04 - Reset/Delete Diagnostic Data
End diagnosis.
If the DTC does return and no malfunction is detected in the wiring and the voltage
supply was OK:
Replace the Motronic Engine Control Module (ECM) J220 . Refer to Motronic Engine
Control Module J220, Replacing .
x-ebahn:///C:/Program%20Files/eBahn/data/VW-A-A4-FU11.ebn/VW/A/A4/Repair%20Ma... 8/7/2009
Closed Throttle Position Switch F60, Checking Page 4 of 4
Final Procedures
After the repair work, the following work steps must be performed in the following
sequence:
End of diagnosis.
Copyright © 2008 Volkswagen of America, Inc. and Bentley Publishers. All rights reserved. Last processed:
x-ebahn:///C:/Program%20Files/eBahn/data/VW-A-A4-FU11.ebn/VW/A/A4/Repair%20Ma... 8/7/2009