Professional Documents
Culture Documents
Quiz 2
Quiz 2
Select one:
a. High RPN value never results in any design evaluation process
b. Less attention
c. High attention
d. No attention at all
If it is found that a column in the relationship matrix in QFD is blank. In this case we should
Select one:
a. Take note but take no action
b. Consider that the corresponding technical descriptor is very important
c. Consider that the corresponding technical descriptor may be omitted.
If we conclude with the help of a Control Chart that a process is in control, it necessarily means that
we will be able to meet the customer requirements
Select one:
a. True
b. False
In the figure shown below, representing a two-factor experiment, there is evidence of ____________
interaction between the 2 factors
Select one:
a. Moderate
b. No
c. Strong
In FMEA diagram, the definition for “how the failure could occur” is tagged under __________
Select one:
a. Mechanisms of failure
b. Occurrence
c. Potential effects of failure
d. Severity
Which of the following is deliberately changed to see the effect on output in a designed experiment?
Select one:
a. Nuisance variables
b. Background variables
c. Factors
When we take the PDSA approach to experimentation, if the result of the experiment is not what we
expected, it means that our assumptions regarding the effect of the change we tried were definitely
wrong
Select one:
a. True
b. False
If the Cp = Cpk for a particular process, it means that the process is necessarily centered about the
target value.
Select one:
a. False
b. True
Which of the following charts always has time as one of the axes, typically the x axis?
Select one:
a. Pareto Chart
b. Histogram
c. Run chart
d. None of the above
Which of the following measures of variation in the data is easy to calculate manually?
Select one:
a. Standard deviation
b. Range
c. None of the above
When we feel that two variables can affect the outcome of an experiment, the preferred strategy is to
_______________
Select one:
a. Conduct one two-factor experiment
b. Conduct two sequential one-factor experiments
If the value of np in 1 and the sample size is 100, the value of p will be ___________
Select one:
a. 100
b. 0.001
c. 10
d. None of the above
Design of experiments can represent _____________ action to bring about improvement in the
system
Select one:
a. Proactive and reactive
b. Only proactive
c. Only reactive
When we conduct experiments, if we take one data point for the “before” condition, and one for the
“after” condition, and we see an improvement, _______________________________
Select one:
a. The change being tested has resulted in the improvement
b. There may be other processes at work resulting in the improvement
Variability in a process may be caused by variability in the incoming material from the same supplier
will typically be classified as ________________
Select one:
a. Special cause variation
b. Common cause variation
If we need to study 4 factors, each at 2 levels, in an experiment, the total number of experimental
units will be _______ in a factorial design.
Select one:
a. 8
b. 16
c. None of the above
If all points in a Control Chart are within the USL and LSL, we can say _____________
Select one:
a. The process is definitely in control
b. Nothing about the process being in control