The document summarizes the design and fabrication of an eight slot geneva mechanism. It includes the aim to design and fabricate the mechanism. The introduction explains that a geneva drive converts continuous rotational motion to intermittent rotational motion through slots and pins. The design section shows the mechanism consists of a driver disc and geneva wheel with 8 radial slots for the pin to travel through and cause intermittent motion. Design calculations determine dimensions like radii, center distance, slot length and width, stop arc radius, and clearance.
The document summarizes the design and fabrication of an eight slot geneva mechanism. It includes the aim to design and fabricate the mechanism. The introduction explains that a geneva drive converts continuous rotational motion to intermittent rotational motion through slots and pins. The design section shows the mechanism consists of a driver disc and geneva wheel with 8 radial slots for the pin to travel through and cause intermittent motion. Design calculations determine dimensions like radii, center distance, slot length and width, stop arc radius, and clearance.
The document summarizes the design and fabrication of an eight slot geneva mechanism. It includes the aim to design and fabricate the mechanism. The introduction explains that a geneva drive converts continuous rotational motion to intermittent rotational motion through slots and pins. The design section shows the mechanism consists of a driver disc and geneva wheel with 8 radial slots for the pin to travel through and cause intermittent motion. Design calculations determine dimensions like radii, center distance, slot length and width, stop arc radius, and clearance.
By Abhijith P Arun Balakrishnan A Athulraj M Divithej P P Aim ● The aim of this project is to design and fabricate eight slotted geneva wheel. Introduction ● Geneva drive is a gear mechanism that uses slots and pins to translate a continuous rotational motion into an intermittent rotary motion. ● The intervel of the irregular motion can be manipulated by changing the pin, slot and shape of the drive and driven wheel. Design Design ● As seen in the above picture, the mechanism consists of two discs, driver disc and a geneva wheel. ● This geneva wheel consists of 8 radial slots through which the pin on the driver disc body travels and causes the intermittent motion of geneva wheel. ● The driver also consists of an extruded semicircular disc which act as the locking mechanism to stop the rotary motion of the geneva disc when the pin is not in one of the slots Design calculation Design calculation a, drive crank radius=30 mm n, no.of slots=8 p, drive pin diameter=9.8 mm t, allowed clearance=0.2 mm c, center distance=a/sin(180/n)=78.3938 mm b, geneva wheel radius=72.4264 mm s, slot centre length=(a+b)-c=24.0326 mm w, slot width=p+t=10 mm y, stop arc radius=a-(p*1.5)=15.3 mm z, stop disc radius=y-t=15.1 mm v, clearance arc=Bz/a=36.4546 mm Results & Discussions Conclusion