Professional Documents
Culture Documents
Sensor Magnético
Sensor Magnético
SENSOR SWITCH
Technical information
WARNING
Do not exceed specification, permanent damage to the sensor may occur.
For reed switch type sensors, polarity must also be observed for the proper functioning of LED. Connect the brown wire in
series with load positive (+) and the blue wire to negative (─) of power source. If the polarity is reversed, reed switch
remains functional but LED will remain in "OFF" state.
BRN
LOAD +
~
POWER
BLU _
~
For solid-state type sensors , polarity must also be observed . Connect brown wire to the positive (+) and the blue to the
negative (─) of DC power source. The black wire must connect to the load only. If the black wire is accidentally
connected to the power source, permanent damage to the sensor may occur.
BRN BRN
Main circuit
Main circuit
+ +
BRL LOAD BRL
( NPN Output ) POWER ( PNP Output ) POWER
BLU _ BLU LOAD _
An external protection circuit may be required if the reed switch is used with inductive load, such as relay or solenoid . For
DC inductive load , attach an external diode parallel to the load and use R-C circuit parallel with AC inductive load as
illustrated below.
DIODE R C
BRN
BRN LOAD
LOAD
Switch
Switch
DC Power +
_ AC Power ~ R:2.7K Ω
BLU BLU C:0.1uf/600V
10M or more
560~1000 μ H
LOAD
As close as possible +
_
Caution for safety
SENSOR SWITCH
Connection method
2 wire S.W. connection
General connection
BROWN
LOAD
Switch
+
- ~
BLUE
General connection
BROWN BROWN
BLACK
LOAD + +
Switch - Switch BLACK -
LOAD
BLUE BLUE
BROWN BROWN
BLACK BLACK
Switch BLUE
LOAD Switch BLUE
+ +
BROWN - BROWN -
BLACK BLACK
Switch BLUE
Switch BLUE
LOAD