Download as doc, pdf, or txt
Download as doc, pdf, or txt
You are on page 1of 4

As stated previously an earth sheltered house uses earth as a form of insulation,

primarily to reduce temperature fluctuations inside the house and reduce energy
consumption. 'Earth sheltered' is a fairly loose term used to refer to a building which
does this to any reasonably significant degree. This includes houses such as the
following:

An earth-bermed house qualifies as 'Earth sheltered'

This diagram shows a section through what is in effect a conventional house with
earth 'bermed' against the walls. It is not incorrect to refer to this house as 'earth
sheltered', however it is more accurate to refer to it as an 'earth bermed' house. The
other basic type of earth sheltered house has its roof covered to some extent with
earth, this type can be more accurately described as 'earth covered'.

Just as there are two basic types of 'earth sheltered' house, there are also many
variations on these two basic types, the rest of this document and indeed the entire
web-site will deal more specifically with 'earth covered' housing. This is because of
the increased energy efficiency of 'earth covered' buildings over 'earth bermed'
buildings. Much of this material is still relevant to 'earth bermed' housing although
usually to a lesser degree.

The following section defining the different types of earth covered houses is adapted
from Baggs et al., pp17-19.

Earth covered buildings can be separated into the following basic types:

A. Above or at ground level


1. Chamber
2. Atrium
3. Elevational
4. Penetrational
B. Below ground level (subgrade)
1. Basement Chamber
2. Recessed Court (Atrium)
3. Wall exposed
4. Recessed Penetrational

Types A1, A2, A3 and A4

These all have their floors located at ground level, or above the ground at the lowest
entrance point or door. Because these type A buildings are not recessed into the earth
where temperatures are more stable they are potentially less energy-efficient than type
B. This type of construction is used when excavation should be kept to a minimum
because of rock, or where a watertable exists near the ground surface. Should extra
rooms be needed in the future, type A buildings are more easily adapted than type B
buildings.

A1 Chamber:

This type of house has an earth-covered roof and berms around all its sides with no
windows. Although such a house would have quite good insulation properties, the
conditions inside would be unlikely to please most people, ie. no natural night.

A2 Atrium:

In Roman times, urban dwellings in particular gained privacy by having their open
space located centrally in relation to the house as a courtyard (atrium) surrounded by
rooms. Consequently, the atrium-type earth-covered building has the spatial
characteristics of the Roman atrium house (combined with those of the A1 chamber
type.)

A3 Elevational:

This is similar to a chamber-type earth-covered building except that it has one wall
exposed. This wall has windows, probably to a view, and preferably to the sun for
passive-solar purposes for which this type is ideal. Side walls may have small areas of
windows with earth-berms up to sill level.

A4 Penetrational:

This type of building has windows to more than one elevation of the building. Of all
the types of earth-covered buildings, this is the least energy-efficient unless special
provisions such as double glazing to doors and windows, or shutters, are used to
conserve thermal energy. However, if windows are used all around, the internal rooms
would not need any skylights, and future extensions would be easier than for other
types. This type has good potential for catching cool breezes in summer. Out of all the
types of earth-covered building this is the closest to a conventional house.

Types B1, B2, B3 and B4

All these types have their floor levels below the ground surface level at the lowest
entrance point or door of the building. Hence, cool air will 'pool' at floor level to a
height equal to the height of the steps necessary for access from floor level up to the
door threshold.

B1 Basement Chamber:

This term is used to describe a building completely enclosed by earth, except for the
entrance/exit. It is the type used for cyclone or tornado shelters. If correctly designed,
it is suitable for nuclear blast and fallout shelters. For various reasons, complete
shopping complexes have been built totally underground (e.g. Japan, Paris and
Montreal). Elsewhere in the world, this type is used for transit networks, defence
complexes and explosives stores. (Again, Not very pleasant to live in.)

B2 Recessed Court:
As explained, the Roman atrium house contained an internal courtyard surrounded by
rooms. In an atrium house (described as 'recessed court' to distinguish it from type
A2) one can stand in the atrium and not be conscious that the house is below ground
level. One normally enters through the atrium, although direct access into the house is
possible. While sometimes awkward to plan, this type is highly energy efficient due to
the large amount of earth insulation and minimal door and wall openings to the
atrium. In very cold climates, the atrium can be covered, while still permitting the
entry of light into the rooms off the atrium.

B3 Wall Exposed:

This type is totally buried beneath earth from the front of the roof to its back edge.
The front is usually the longest edge of the roof. The rear wall is fully earth insulated
and often so are the side walls. This type with an elongated rectangular plan, can
balance good insulation of three walls, floor and roof with an exposed front wall. This
provides all front rooms with a view, and approaches the appearance of a conventional
home. However, solar gain and thermal losses all need careful design consideration
when complete wall areas are exposed.

B4 Recessed Penetrational

This type of building, constructed in a previously prepared excavation, has windows


and/or doors to the back and front elevations. This type represents only a slight
increase in energy efficiency over type A4 and is thus potentially one of the least
energy efficient possibilities.

You might also like