The document describes tests to determine the compressive and tensile strength of stones. For compressive strength testing, cube or cylinder specimens of at least 50mm are soaked in water for 3 days and then dried before being placed under increasing compressive load until failure. The maximum load is then divided by the specimen area to calculate compressive strength. Tensile strength testing is also described but no details are provided in the given text.
The document describes tests to determine the compressive and tensile strength of stones. For compressive strength testing, cube or cylinder specimens of at least 50mm are soaked in water for 3 days and then dried before being placed under increasing compressive load until failure. The maximum load is then divided by the specimen area to calculate compressive strength. Tensile strength testing is also described but no details are provided in the given text.
The document describes tests to determine the compressive and tensile strength of stones. For compressive strength testing, cube or cylinder specimens of at least 50mm are soaked in water for 3 days and then dried before being placed under increasing compressive load until failure. The maximum load is then divided by the specimen area to calculate compressive strength. Tensile strength testing is also described but no details are provided in the given text.
Test pieces should be in the form of cube or cylinder. Diameter should be equal to its height and it shouldn’t be less than 50mm (2”). Specimen should be placed in water for 3 days at (20-30)℃. After placing it in oven at 105±5℃ for 24 hours the specimen is then tested in saturated conditions. Rate of load applied on specimen should be 14N/mm², until the specimen breaks. Maximum load divided by the area of specimen is the compressive strength of the specimen (i.e. stone). Tensile Strength Test