Professional Documents
Culture Documents
Double Tee Joint Double Tee Joint With A Door
Double Tee Joint Double Tee Joint With A Door
GEOMETRY
In the contour popup box, select the filled in the option column
and select interior solid in the surface.
Click display in the contour option so that get the pressure
contour.
Click on the contour map option and click general in type of
number format option.
Click on the pressure below the “contours of” select velocity to
display the velocity contour and click the display option.
Click on the drop down the new surface menu and select plane
option.
To insert the animation for the moving particles of fluid, there is
an option animation. click that option and click the necessary
streamline and contour to include the animation with required
speed and number of particles
SETUP
ITERATION
MESH
Meshing is defined as making the entire design into meshes inorder
to obtain the outputs in small components and then integrate it into
larger components to obtain the results and outputs.
VELOCITY ANALYSIS:
The velocity analysis is implemented by selecting the stream line and
the particular contour. The velocity analysis is analysis which
indicates the velocity of the fluid that flows within the structure with
respect to time and distance, which ultimately provides us the flow
rate. The velocity analysis can be done for either along the stream
line motion or on the walls of the structure such as in pressure
contour. Velocity analysis provides us the information which is
significant for the construction of the design and there analysis.
VOLUME RENDERING
PRESSURE ANALYSIS
After the velocity analysis and volume rendering wwe can proceed to
pressure analysis. Here in this case pressure varies through out the
1000 iterations for various temperatures and area of the design.
Generally pressure analysis is vety important for designing a
structure, because it gives the ultimate requirement of the structure,
the stability, strength and the reliability of any structure.
RESULT
The analysis are done for the double tee joint where the water flows
in through two inlets and output is obtained at the other two outlets.
Finally the results are obtained for various inputs.