Professional Documents
Culture Documents
Biomed Group 1: Electronic Stethoscope
Biomed Group 1: Electronic Stethoscope
sounds regularly
P R O S A N D C O N S Feedback is present due to E - STETHOSCOPE FLOW
wire shortage. To aid this
The circuit is made from problem, the wire length can
analog components, which is be adjusted.
a bit outdated, but the
M E T H O D O L O G Y
project performs better than
the standard stethoscope C I R C U I T D E T A I L S
used by medical The research project is
professionals. mainly focused on proving The electronic stethoscope is based on
that the main component of two low cost IC: a TL074 quad op amp
Not only that it performs and an LM386 power amplifier IC. The op
the circuit, which is the amps are used for amplification and
better than the standard, it is
TL074 quad op-amp IC and filtering of the signal from piezo element
also made of low-cost in the chest piece. The power amplifier
LM386 power amplifier IC
materials and can be drives the headphone or loud speaker.
developed further for future
can be used for Signal from the electret mic condenser is
innovations. amplification and filtering applied via CON1, 3.5mm socket and a
100nF to op-amp IC1c. The associated
of signal from the electret 33pF capacitor and 100 ohms resistor
Standard stethoscopes used mic condenser in the chest attenuate high frequencies and thereby
by medical professionals piece. reduce the possibility of picking up radio
degrades its quality over time signals. IC1c is biased at 4.3V via the 1M
Conventional Stethoscope Flow ohm resistor connected to 10k ohms
and its ability to detect sound voltage divider resistors across the 8.6 V
cannot be adjusted. On the supply. The 1M ohms resistor also sets
other hand. this electronic the input impedance of the amplifier.
stethoscope can be adjusted
based on the user’s
preferences.