Santen
SANTEN INCORPORATED MATERIAL SAFETY DATA SHEET
SECTION 1. Chemical Product and Company Identification
Product (Trade) Name: ALAMAST™ MSDS Preparation Date: June 2, 2000
Product Description: Ophthalmic solution
MANUFACTURER: CONTACT INFORMATION:
SANTEN INCORPORATED Telephone: (707) 254-1750
555 Gateway Drive Facsimile: (707) 254-1760
Napa, CA USA 94558
SECTION 2. Composition/Information on Ingredients
Component) Synonym Formula MW] Approximate CAST
Percent
Weightweight
“Gheorn Giycoroh, HOCH:CH(OH)GREOH | 92.1 <2 BETS
Giycyl alcoho!;
12,3-
Propanetri zs
Pamirolast | 9-methyl-3(1H- | CiohiKNeO 286.3 Ot 700299-089
Potassium — | tetrazol-5-yi)-4H-
pytidoft,2-0)
pyrimidin-4-one
potassium salt
Tauraikonium | N.N-Dimethyl-Ne | CayHosNeCl 33997 (01005 139-077
chloride Dodecy
Benzene
methanaminium
chloride;
Laury! Dimethyt
Benzyl
‘Ammonium
chloride
SECTION 3. Hazards Identification
Emergency Overview: This product has been approved for the uses identified on the
package insert. Use only as directed by this information.
SECTION 4, First Aid Measures
No specific medical treatment is necessary for skin or eye contact since this material is
intended for topical ophthalmic use. Do not inhale mist or ingest. If inhaled or
swallowed, rinse mouth out with water. Seek medical attention if adverse health
symptoms develop.
SECTION 5. Fire Fighting Measures
Flash Point (C): Not applicable,
Flammable Limits (LEL & UEL %): Not applicable.
Auto Ignition Temperature: Not applicable,
ALAMAST™ MSDS
Page 1 of 3Santen
SANTEN INCORPORATED MATERIAL SAFETY DATA SHEET
SECTION 5. Fire Fighting Measures (continued)
Extinguishing Media: Not applicable.
Fire Fighting Procedures: Not applicable.
Fire & Explosion Hazards: Not applicable.
SECTION 6. Accidental Release Measures
Spill containment, treatment, and clean-up procedures:
No special spill containment or treatment is necessary. Absorb spill with inert material
and place in a disposal container.
SECTION 7. Handling and Storage
Keep container closed. Store at temperatures and conditions indicated on the package
insert
SECTION 8. Exposure Controls/Personal Protection
Ventilation and Engineering Controls: No special controls are required.
Respiratory Protection: Respiratory protection is not necessary.
Eye protection: Eye protection is not applicable.
Skin protecti Skin protection is not necessary.
SECTION 9. Physical and Chemical Properties
Physical and chemical properties of product determined as a whole.
Appearance and Odor: Clear, colorless to light yellow liquid,
pH: Approximately 8
Specific Gravity (H,O Approximately 1
Boiling Point (C): Approximately 100°
Melting Point (C): Approximately 0°
Vapor Pressure: ND
Evaporation Rate: ND
Solubility in Water: Soluble in all proportions.
N/D = Not determined.
ALAMAST™ MSDS.
Page 2 of 3Santen
SANTEN INCORPORATED MATERIAL SAFETY DATA SHEET
SECTION 10. Stability and Reactivity
Stability: Stable.
Hazardous Polymerization: Hazardous polymerization will not occur.
Hazardous Decomposition: Hazardous decomposition will not occur.
Conditions to avoi Contact with strong acids, bases, or oxidizers.
SECTION 11. Toxicological Information
For product specific information, including precautions, adverse reactions, and dosage,
refer to package insert.
SECTION 12. Ecological Information
Data not yet available.
SECTION 13. Disposal Considerations
Dispose of material in accordance with local, state, and federal regulations.
SECTION 14, Transport Information
DOT Proper Shipping Name and Identification Number: Not regulated,
Hazard class: Not applicable.
SECTION 15. Regulatory Information
Occupational Airborne Exposure Limits for Glycerin:
OSHA Permissible Exposure Limit (PEL): 10 mg/m* total dust, 5 mg/m? respirable
fraction for glycerin (mists). ACGIH Threshold Limit Value (TLV): 10 mg/m’ for glycerin
mist containing no asbestos and <1% crystalline silica.
SECTION 16. Other Information
The information provided herein represents the most reasonable current information
available when this assessment was performed. It is believed to be accurate and
dependable. Santen Incorporated makes no representation as to the accuracy or
sufficiency of this information. This product is intended for human ophthalmic use only.
Use only as directed by package information, Santen Incorporated will assume no
liability for the improper use of this product.
ALAMAST™ MSDS
Page 3 of 3