Professional Documents
Culture Documents
FB2018 Hose Clamp Guidelines
FB2018 Hose Clamp Guidelines
The following document applies to hose clamps that may be allowed or disallowed at Formula Bharat
2018. For concerns, email formulabharat-rules@googlegroups.com.
The table below shows the types of clamps that will be allowed / disallowed at Technical Inspection.
Type of clamp Allowed / Remarks
Disallowed
Mobility Engineering Consortium Private Limited Released: December 26, 2017 | S.V. Page 1 / 5
HOSE CLAMP GUIDELINES
Mobility Engineering Consortium Private Limited Released: December 26, 2017 | S.V. Page 2 / 5
HOSE CLAMP GUIDELINES
Although this is a
3660 degree wrap,
this behaves like a
Disallowed U-clamp on
tightening,with a gap
just below the bolt.
Although this is a
3660 degree wrap,
this behaves like a
Disallowed U-clamp on
tightening,with a gap
just below the bolt.
Mobility Engineering Consortium Private Limited Released: December 26, 2017 | S.V. Page 3 / 5
HOSE CLAMP GUIDELINES
Sharp edges of
clamp can cut
through the rubber.
Disallowed The ends need to be
rolled.
3. While tightening a hose clamp, it needs to be over the annular ring or beaded end. It
shouldn’t be over torqued such that the rubber on each side of the clamp is higher than the
Mobility Engineering Consortium Private Limited Released: December 26, 2017 | S.V. Page 4 / 5
HOSE CLAMP GUIDELINES
clamp surface. Anything similar to the image below will not clear TI.
- Correct
Mobility Engineering Consortium Private Limited Released: December 26, 2017 | S.V. Page 5 / 5