UCS To change the crosshair at an angle in reference to lines, objects or etc.
UCS.ENTER To change the crosshair back to world coordinate @ 0deg
EPDFSHX 0 = Without text frame in PDF format 1 = With text frame in PDF format PLAN To change the view of model in reference to the active UCS. PSLTSCALE System variable controls the linetype scaling of objects displayed in paper space viewports. 0 = No special linetype scaling 1 = Viewport scaling governs linetype scaling MSLTSCALE System variable controls whether or not linetypes displayed on the model tab are scaled based on the annotation scale. 0 = Linetypes displayed on the Model tab are not scaled by the annotation scale 1 = Linetypes displayed on the Model tab are scaled by the annotation scale SNAPSTYL To navigate from plan to isometric. 0 = Plan 1 = Isometric Note: 1) F5 to alternate the curse to different orientation. 2) Tool Ellipse → Isocircle 3) Dimension - Use dimension Align tool to draw the dimension. Make sure correct iso- plan is used. - To convert to iso-dimension, use ObliqueDimension (Select the dimension) → 90deg 4) Dimension (2) - Use dimension Align tool to draw the dimension. - DIMEDIT → Oblique → Select the line where the dimension line to be parallel with. - DIMTEDIT → Angle → Select the line where the text to be parallel with. 5) Text - Use TEXT - Specify the height and width to the angle of desired iso-plane. - Manual change the property under “Text” tab, Angle/Oblique to either +30deg or -30deg. VISRETAIN To update xref file to latest. Change the value from 1 to 0. # followed by To change from relative (default) to absolute coordinate. coordinate BURST To burst attribute. FILTER ATTEXT Eg.: DOORTYPE C003000 – C:Character, 003:3length, 000:nodecimals AREA N010002 – N:Intergral, 010:10digit, 002:2decimals RIGHT_CLICK + Y Move. RIGHT_CLICK + T Select similar. LAYWALK LAYISO FIND Find & Replace LAYDEL AUDIT Cleans unused entities from the file and any unused xrefs BATTMAN Block Attribute Manager (Globally change the attribute properties)