Professional Documents
Culture Documents
NTU
NTU
USER’’S MANUAL
USER
TABLE OF CONTENTS
1. Product Description
2. Product character
3. Environment requirement
4. Dimension
5. Operate manual
1. Product Description
multi-mode fiber. The fiber for transmit data can be used to monitor
and control local and remote devices, and no collision will occur. It
2. PRODUCT CHARACTER
devices.
a. Rate: 2.048Mbit/sw±50ppm
b. Coding: HDB3
4. DIMENSION
5. OPERATE MANUAL
5.2 Indicator
There are seven indicators on the front panel, from left to right as
following:
Name Color Status Description
on E1 wire disconnect warning
E1LOS red
off E1 work normally
E1LOF red on spare
on Local fiber signal loss warning
OLOS red
off Local fiber signal is normal
OLOF red spare
Local or remote device in testing status when any of
on
TEST yellow ANA,DIG,REM,PATT is pressed
off The device work normally
on PRN tested normally when PATT is pressed
PTOK green off PRN can’t go through test when PATT is pressed
flick PRN test has error code when PATT is pressed
on Power supply is on
PWR green
off Power supply is off
There are four button switchers on the front panel; they are as
normal..
whether local device and its connecting line work normal
Fiber
E1 E1 FOM
Interface
Interface
wire..
remote device and optical wire
Fiber
E1 E1 FOM Interface
Interface
E1 FOM
E1 FOM
E1
FIBER
Interface
� PATT
PATT: PBRS Code testing. To produce and transmit the
match,, the
signal of E1 match that PBRS standard. If match
PTOK light on, otherwise, off. By this way, the status of the
Process FIBER
REV & CHK circuit
E1
Loop 1
Loop 2
available.
Note:
� Push down any switch on front panel will terminate the normal
communication, and turn into the test mode.
� During the PATT model testing, the circuit should be loop by
5.66 E1 receptacle
5.
75Ω/120Ω auto-negotiation
6. Package and installation
6.1 Package
E1 Fiber Modem is packaged with special box, protected by
shockproof foam, one device in one package.
User’s manual----------------------------------------------- 1
BNC --------------------------------------------------------- 2
� Cross screwdriver
� Multimeter
� Electric iron
6.3.1 Unpacking
� Please check the packing list enclosed with the device for the
Please screw off the plastic protection cap from the connector before
installation, and then connect with the exact fiber according the mark
of TX and RX. Take care that the input and output fiber should not be
If the device test normally as the above, please pushes up all the
buttons on the front panel and turn off the power supply, insert E1 out
put wire; turn on the power supply, then the device work normally.
6.3.5 If all LEDs are working not as above, please make the reference
to the MALFUNCTION DIAGNOSES AND ELIMINATE. If not
successful, please contact with us in time.
PWR is ON, others are OFF when the device work normally
NOTE
NOTE:
5. Whenever there is a fault, try to identify the problem and the alarm.