Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

DIGITAL TEMPERATURE CONTROLLER

2. MOUNTING SIZE
INSTRUCTION MANUAL 48mm*48mm 48mm*96mm
Unit:mm 96mm*48mm

44.0
Unit:mm

44.0
Please Carefully read all the instructions in this manual. 50 14.6
Please place this manual in a convenient location for easy reference.
50 14.6

S P E C I F I C AT I O N

90.0

104.0
44.0
58.0

96
50
● Power Supply: 85~265VAC 50/60HZ, 24VDC or 24VAC available on request
● Input: : Thermocouple(K,E,J,N,Wu3_Re25,S,T,R,B,) Pt100( Up to 800 C)
1
Voltage and Current(0-5VDC,0-10VDC,0-50mV,4-20mV,0-20mA 2-10VDC, 1-5VDC, 4-20mA) 1
1 3 .6 80 1
1
● Display: Dual line 4 digits LED display 13 . 6 80
● Output: RELAY/SSR DRIVE/4-20mA/0-5VDC/0-10VDC/1-5VDC(specify when order)
● Power consumption: 5VA maximum 72mm*72mm 96mm*96mm
Unit:mm Unit:mm
● Control method: PID, ON/OFF(P=0), Time proportional control(I=0, D=0)

67.5

90
● Measuring accuracy: 0.2%F.S
● Decimal points for all input signals: 0.1 resolution for thermocouple. 0.1 resolution for RTD.

UP

UP
0.001 for analog input
74 14.6 96 14.6
● Modbus RTU RS-485 communication, SV/PV 4-20mA Re-transmission
● Output bar graphic indication( for analog output such as 4-20mA only)
● Controller can display based on Centigrade or Fahrenheit, switchable between each other.

104.0
80.0
67.5

90.0
74

96
● Alarm Standby function intergrated
● Power up overshoot suppression function intergreated.
● Analog output buffer function 1 1
1
13. 6 1
● ON/OFF Control: Set P=0.0,it will be changed as on/off control. Check 80 13.6 80

manual"6.1 parameter P " . Position difference is HYS. when heating :PV>SV, OUT
stop, when PV<SV-HYS, OUT start, fitting for OUT1. When Cooling:PV>SV+HYS,
output start, when PV<SV,output stop. 3. WIRING
● When anolog signal output, can using output buffer function when in some special
48mm*48mm 48mm*96mm 96mm*48mm 96mm*96mm
control position, which can make output more stable.
Check manual (6.1 level 2 bUFF parameter, and 6.3 level 2 bEr parameter) 1 L AC85-265V N 6 1 L 11
AC85-265V AL2
AL1 A+ 11 VDC,mA
2 RS -485 7 2 N 12
NO B- 12 ANL4/ANL3
RTD
IN
NO
3 8 Voltage mA,V
1. Unique Features OUT For
SSR mA,V
DA - AL2
13
B
3 OUT For SSR Current
NC
13
4 TRS
B
9 NO
Power Up Overshoot Supression NO TC
14 4 14
The overshoot is common when controller just power up, and the PV is getting closer to SV,
5 DA + NO A 10 B-
RS-485
this controller offers a useful features for application where the overshoot should be tolerated AL1
5 A+ 15
72mm*72mm NO
DA -
DA - AL2 6 16
SV
OverShoot
SV
Overshoot suppressed
1 L B- 8 8 TRS
AC85-265V RS -485 TRS VDC/mA
PV PV NO 7 17
2 N A+ 9 DA +
9 ANL4/ANL3 IN
DA+

NC RTD
AL1 8 18
3 10 10 B
NO
Figure 1 Figure 2
VDC/mA 9 B 19
4 11 11 TC
The figure 1 shows significant overshoot after PV reaches to SV, this is harmful to some of ANL4/ANL3 IN
system, MTA offers a feature to suppress the overshoot OUT RTD 10 A 20
5 12 B 12
LED display and indicator built together on one PCB board NO For Alarm output rated:
SSR mA,V B Relay contact output:250V AC, 3A (Resistive load)
6 NC
13 13 Control output rated:
The LED display and LED indicators was built as one panel TC Relay contact output: 250V AC,5A(Resistive load)
,most of controller with their LED display and LED indicator Voltage pulse output: 0/12 V DC or 0/24V DC (Load resistance
installed separately, the chance of the malfunction is high. 7 14 A 14 600 ohm or more)
This controller with all the display and indicator units built Current output: 4 to 20mA DC (Load resistance 500 ohm or less)
together on board, makes it easier to install and easy to test Triac single phase zero crossing: 100A or less
with higher reliability.
3.1 Wiring cautions Twist these leadwires
instrument power

PV/SV Re-transmission(Optional function) IN OUT Instrument


Noise filter power
terminals
Shorten distance between Minimize
The PV or SV value can be re-transmitted as analog signal pitches distance
0-5VDC,0-10VDC,4-20mA, and the re-transmission signal
can be feed to recorder ro digital display 4. PANEL DESCRIPTION
1 Mea sured val ue (PV) di spl ay [RED]
C or F display selectable 2 Se t val ue (SV) di spl ay [GREEN ]
3 OUT1 lamp : Out pu t ind icat ion
1
C to F This controller offers display based on Celcius and OUT2 lamp : Rema rk lamp
OUT 1 OUT 2 AT AL1 AL2 AL3 MAN COM PRO OUT 1 OUT 2 AT AL1 AL2 AL3 MAN COM PRO
Fahrenh-eit. can the display is switchable between C and F. AT lamp : Autot un ing ind icat ion
OU T% 10 20 30 40 50 60 70 80 90 100 OU T% 10 20 30 40 50 60 70 80 90 100

F to C AL 1 lamp : Al ar m 1 ou tpu t ind icat ion


MAXWELL MTA-72 MAXWELL MTA-72
2 AL 2 lamp : Al ar m 2 ou tpu t ind icat ion
AL 3 lamp : Rema rk lamp
Decimal points for all input signals 3 OUT1 OUT2 AT AL1 AL2 AL3 MAN COM PRO
MAN lamp : Rema rk lamp
4 OUT% 10 20 30 40 50 60 70 80 90 100
COM lamp : Comm un icat ion ind icat ion
The decimal points display is available for all input signals. For TC and RTD sensors, the
PRG lamp : Rema rk lamp
resolution is 0.1, for analog signal, the resolution is 0.001. 5 4 LE D ba r: O ut pu t1 % val ue ind icat ion
Output restriction for analog output 5 SET key: Us ed for pa rame ter cal ling up an d set
val ue regi strat ion
Controller offers a function when output is analog such as 4-20mA, to maintain a stable 6 : Sh ift key an d sett ing SV key
system, the output changing rate can be restrained in a certain range, for example, if the out- 7 : Down key, de creas e numbe rs
put changes from 4mA to 8mA in 1 seconds, then the changing rate is 4mA/S, the changing 6 7 8 8 : Up key ,inc reas e numbe rs
rate can be restrained within 5%,means in the next seconds, the output only changes between
4mA*(1-5%) to 4mA*(1+5%). which is 3.8mA to 4.2mA.
6.3 Level 2
5. SETTING Press the key while pressing the SET key for 3 s to PASS, set PASS=0101,
then press SET key to Level 2
5.1 Basic operation flow charts The following parameter symbols are displayed one by one every time the SET key is pressed.
Power on
PV After the value be registered ,when no parameter setting is required, Press the SET key for 3 s
Power on
SV
to return the instrument to the normal display. 1# Factory set value
Symbol Name Range 1# Description
Edition code
Input type display PV Main input Setting
Edition code type select Input K E J N Wu3_Re25 S T R B
SV

Range 1300°C 600°C 800°C 1300°C 2000°C 1600°C 400°C 1700°C 1800°C

PV/SV display mo de PV Setting


(Normal display) INPUT1
SV
Input 2-10VDC 0-10VDC Pt100
Scale & type display 1-5VDC 0-5VDC 0-50mV 0-20mV
Range 4-20mA 0-20mA 800°C
Press key SET 0,1 for TC or RTD or analog type
SV setting mo de PV Decimal point 0 to 3 0
Set range high 2,3 Only for Linear analog type input
Press the SE T key SV SV lower limit value
for 3 seconds SET Set range low
Low setting -1999 to 99990 Lower point of transmission
Leve l 1 High setting -1999 to 9999400 SV higher limit value
Press the key and Higher point of transmission
SET simultaneously PV/SV display mode Display scale C ,F or A C
for 3 seconds SET :Centigrade, :Fahrenheit :without scale
PASS (Normal display) PV follow-up
0 to 60 55 PV variable-value control,
PV input filter 0-30: for general, 31-60: for enhanced
Lower limit for -199~9999 0 Lowes t value display when linea r ana log inpu ts
Display PV display ,Suc h as 4-20mA inpu t.
Input J 2-10VDC 0-10VDC Pt100
Highe r limit for -1999~9999 2000 Hi gh es t va lue di sp lay when line ar an al og inp ut s
K E N Wu3_Re25 S T R B PV displ ay
1-5VDC 0-5VDC 0-50mV 0-20mV ,Suc h as 4- 20 mA inp ut .
Range 1300°C 600°C 800°C 1300°C 2000°C 1600°C 400°C 1700°C 1800°C 4-20mA 0-20mA 800°C
Alarm1 mode 00 to 16 11 Select the type of alarm 1 ,See(**ALARM TYPE TABLE)
5.2 Setting set value(SV) Alarm1
diffe rentia l gap 0.0 to 100.0 1.0 Alarm1 diffe rentia l gap setti ng
Example: Following is an example of set value(SV) to 200℃
(1)Set to the SV setting mode (2)Shift of the digit brightly lit (3) Numeric value change (4) Set value entry Alarm2 mode 00 to 16 10 Select the type of alarm 2 ,See(**ALARM TYPE TABLE)
Alarm2
PV PV PV PV
diffe rentia l gap 0.0 to 100.0 1.0 Alarm2 diffe rentia l gap setti ng
SV SV SV SV Control action HEAT or COOL HEAT :Rever se act ion (Heati ng) :Dir ect act ion (Cool ing)
In the normal display Press the shift key to Press the UP key to set "2". After finishing the setting, Press Buffer mode 0,1,2 0 0: No buff er for analog output 1
modePress key shift the digit which lig hts Pressing the UP key increase the SET key, All of the set value for out1analog 1: Always with buff er for analog output 1
to enter the SV setting brightly up to the hundreds numerals, and pressing the digits stop flash and as a result output 2: With buff er when the output 1 increases only . (Soft -st art )
mode. The digit which dights DOWN key decrease the instrument return to Output vari ance val ue percent age per second buff er limit
flashing is configurable. numerals. PV/SV display mode. accordi ng BUFF in Level1
Device address
5.3 Setting parameters other than set value (SV) setting 0-127 1 Communication device address setting.

The setting procedures are the same as those of example (2) to (4) in the Band-ra te setti ng 9.6 BAUd=2.4K,4.8K,9.6K,19.2K
above "Setting set value (SV)". Press the SET key after the **ALARM TYPE TABLE (ALd_=00~16)
setting end shifts to the next parameter. When no parameter setting is 10: No alarm output 00: No alarm output
required, return the instrument to the PV/SV display mode. 11: Deviation high alarm 01: Deviation high alarm with hold action
12: Deviation low alarm 02: Deviation low alarm with hold action
6. LEVEL 13: Deviation high/low alarm 03: Deviation high/low alarm with hold action
14: Deviation band alarm 04: Deviation band alarm with hold action
*In any ti me you can pre ss SET key fo r 3 seconds to save value and exit level to PV/S V mode. 15: Process high alarm 05: Process high alarm with hold action
16: Process low alarm 06: Process low alarm with hold action
6.1 Level 1
Press the SET key for 3 seconds to level 1: NOTE: With hol d act ion, When Hod act ion is ON, the alarm act ion is suppressed
at start-up unt il the measured val ue ent ers the non-al arm range.
The following parameter symbols are displayed one by one
every time the SET key is pressed.After the value be
registered ,when no parameter setting is required, Press the SET key for 3 s to return the
7. AUTOTUNING
instrument to the normal display. 1# Factory set value Auto-tuning shall be performed right after the power feed to controller when PV is far away from SV.
Symbol Name Range 1# Description Aut otuning At
NO or YES NO
Press SET key for
Autotuning YES: Autotuning on,NO: Autotuning off SET PV PV

Set the alarm value for alarm 1 .


3 seconds to start
-1999 to 9999 10
Alarm 1 Alarm differential gap=AH1
SV SV
autotuning
-1999 to 9999 10 Set the alarm value for alarm 2 Press key to set At=YE S
Alarm 2 Alarm differential gap=AH2 Press SET key for 3 s to Level1
PV bias -199to 199 0.0 Sensor correction is made by adding bias 1, When begin to autotuning, AT light flash, which means to begin to autotuning,if you want
value to measured value(PV). to exit from autotuning, please enter into the AT menu, set AT=no
Proportional 0.0 to 200.0 30.0 Proportional band in PID with unit ℃ for OUT1 2,In the middle of the autotuning, it is ON/OFF control, according to the different systems,
band P=0.0, ON/OFF control temperature may be have a big variance and the autotuning time is of a long short.
Control 0 to 999 1.0 Contro l out diffe rentia l gap=HYS 3,After finishing autotuning, AT light stops flashing, controller will automatically save P、
Hysteresis Only for ON/OFF actio n when P=0.0 I、d、rE、rSt parameters,then automatic return to the normal control state, controller
will continue to run with new P、I、d、rE、rSt parameters value.
Integral time 0 to 3600 s 240 Set the time of integral action to eliminate
the offset occurring in proportional control.
Der ivat ive time 0 to 3600 s 60 Set the time of derivati ve acti on to improve 8. INPUT RANGE TABLE
con trol stabi lity by prepa ring for output cha nges.
Proportioning Input type Code Input type Code
Cycle
0 to 999 s 20 Proportioning cycle time for PID control 0 0
0 to 400 C K A4 0 to 400 C D A4
Overshoot 0.0 to 100.0 5.0 Overshoot protection for first power on or SV modify later. K 0 to 600 0C K A6 Pt100 0 to 600 C
0
D A6
protection (Auto setting after autotuning) 0 to 1300 0C K B3 0 to 800 C
0
D A8
0
Proportional -199 to 200 0.0 Proportional reset for overshoot protection 0 to 200 0C E A2 -100 to +200 C D C2
0
reset (Auto setting after autotuning) E 0 to 0
400 C E A4 -200 to +800 C D C8
0 to 600 0C E A6 -100.0 to +200.00C D F2
Output limit 0.0 to 100.0% 0.0 Output manipulated variable lowest limit -50.0 to +200.00C D G2
(Low) 0 to 400 0C J A4
J 0 to 600 0C J A6
Ou tput limi t 0.0 to 100.0% 100.0 Output manipulated variable highest limit 0 to J A8 Input type Code
800 0C
(High) 0 0 to 20mV V 01
0 to 200 C T A2
Output buffer 0.0 to 100% 100.0 Out put varianc e value per centage per second T 0 to 300 0C T A3 0 to 50mV -1999 to 9999 V 02
buf fer limit Onl y for 4-20mA out put 0 to 400 0C T A4 0 to 5VDC -199.9 to 999.9 V 03
LCK=0: Allow to modify any param eter and SV 0 to 10VDC V 04
Set data lock 0-2 0 S 0 to 1600 0C S B6
LCK=1: Only all ow to modify SV and AT R 1 to 5VDC -19.99 to 99.99 V 08
0 to 1700 0C R B7
LCK=2: Not all ow to modify any param eter and SV B 200 to 1800 0C B B8 2 to 10VDC V 09
-1.999 to 9.999
N 0 to 1300 C
0
N B3 4 to 20mA A 03
6.2 PASS Press the key and the SET key simultaneously Wu3_Re25 600 to 2000 C
0
W B0 0 to 20mA A 02
for 3 seconds.
PASS Note: Clients can set TC, RTD by keyboard ,please set the input type coincide with thesensor. Check details
of the manual"6.3"parameter INP1,If need analog signalinputs, please specified when order.
PV PV
(Except 0-20mV or 0-50mV input)
Level 2
Set PASS=0101 Press SET key PV

SV SV
SV

You might also like