Professional Documents
Culture Documents
Wapda Hydel Electronics
Wapda Hydel Electronics
13 NOVEMBER 2016
A. Thermal relay
B. Overcurrent relay
C. None
A. BJT GTO
B. BJT, MCT
C. BJT GTO MCT
D. MCT GTO
4) Surge impedance of long transmission line.
A. 50
B. 75
C. 400
D. 800
A. core
B. primary winding
C. secondary winding
D. mutual flux
6) In an ideal transformer,
14. Power plants using coal work closely on known which of the following cycle?
A. Otto cycle
C. Brayton cycle
D. Rankine cycle
17. Coking is
B. heating of coal in absence of air, driving out CO2 and leaving behind the residue and carbon
D. producing lumps of coal from fine powders with the help of a binder.
18. The output of a solar cell is of the order of
A. 0.1 W
B. 0.5 W
C. 1 W
D. 5 W.
A. fuel
B. moderator
C. shield
D. regulator
20. As compared to steam at entry to the turbine, which of the following will be larger at exit?
A. Pressure
B. Flow rate
C. Specific volume
D. Specific enthalpy.
A. diameter of conductor
B. (diameter of conductor)1/2
C. (diameter of conductor )2
22. Total load transmitted through a 3 phase transmission line is 10,000 kW at 0.8 power factor
lagging. The I2R losses are 900 kW. The efficiency of transmission line is
A. 60%
B. 90%
C. 95%
D. 99%.
23. Shunt capacitance is usually neglected in the analysis of
A. R-phase conductor
B. Y- phase conductor
C. B-phase conductor
D. Earth conductor.
26. The number of cycles in which a high speed circuit breaker can complete its operation is
A. 3 to 8
B. 10 to 18
C. 20 to 30
D. 40 to 50
A. Conduct
B. switch
C. thick wire
D. fuse
28. Which of the following is a product of root mean square (rms) value of applied voltage and
current?
A. Reactive power
B. Virtual power
C. Active power
D. Apparent power
A. P.F
B. Active factor
C. Reactive factor
D. Apparent factor
A. Reactive power
B. Virtual power
C. Active power
D. Apparent power
A. An inductive circuit
B. A capacitive circuit
C. R-L circuit
D. R-C circuit
A. Inductive factor
B. Gain factor
C. Q-Factor
D. Inductive factor
33. The DC operating point of an amplifier specified by the voltage and the current value is called
A. Q point
B. Load line
C. Gain
D. None of above
35. The element with valence electrons in higher energy level as compared to silicon
A. Germanium
B. Arsenic
C. Copper
D. Carbon
B. it runs at full-load
A. Noise Immunity
B. Less size
C.
D. All of the above
A. PN Junction
B. Drain
C. Gate
D. Source
B. Megger
C. Wattmeter
D. Voltmeter
41. Benefit of hot wire instrument? (Answer was Option B according to NTS key)
42. Drawback of hot wire instrument? (Answer was Option C according to NTS key)
44. Oscillator whose frequency can be changed by a variable DC control voltage is?
A. Triangular-wave oscillator
C. Crystal oscillator
A. Xc large
B. Xl large
C. Xc small
D. Xl small
46. ---------- waves produce when E.F couple with M.F (Electromagnetic)
A. 1st part
B. 2nd part
C. intermediate
D. auxiliary
B. CDMA
C. SDMA
D. TDMA
50. Leakage current in transistor due to minority carriers is (Reverse leakage current)
51. Like electric charge, there are no magnetic charges in a magnetic field. This statement refers to?
A. Gausses Law
B. Faraday’s law
C. Newton law
A. General purpose
B. Schotky
C. High speed
D. low speed
54. In standards definition of electronics the relation between Vo and Vbr is.
A. vo < vbr
B. vo > Vbr
C. vo=vbr
D. none
56. Multi-phase rectifier increase ----------- and decrease --------- (DC & Harmonics)
C. Biomass
D. Both A & B
A. Ammeter
B. Ohmmeter
C. Flux meter
A. 16
B. 64
C. 32
D. 128
A. Power dissipation
B. Inductive current
C. Capacitive voltage
A. active
B. passive
C. bilateral
D. none of these
A. amplifier
B. filter
C. oscillator
D. none
A. 1st Quadrant
B. 2nd Quadrant
C. 3rd Quadrant
D. 4th Quadrant
71. Line commutation related to Thyristor rectifier
A. Diode Rectifier
B. Thyristor Rectifier
C.
D. Triac Rectifier
A. Voltage source
B. Current Source
A. Zero
B. Infinity
78. The region of operation of transistor is ………….. if Emitter junction is forward biased and collector
junction is reverse biased.
A. Active region
B. Saturation region
C. Inverted
D. None of these.
79. LVDT is a/an …………………... device.
A. Mechanical
B. Electromechanical
C. Electrical
D. Thermal
D. All of above