Professional Documents
Culture Documents
Deck Support Container
Deck Support Container
D
LA
Question asked (193):
When you join a new ship, how are you informed about safety rules, alarm instructions
and your own duties in case of an emergency?
Selected answer (score 0):
Don't know
Correct answer:
By muster lists exhibited in conspicuous places
On the diagram, which letter indicates what is meant by the word "DRAUGHT" of the
ship?
Selected answer (score 0):
Don't know
AR
Correct answer:
Draught is indicated by D, in the figure
could be the correct direction associated with the term "HEAD LINE". Which one is the
correct one?
Selected answer (score 0):
Don't know
Correct answer:
Head line is given by B on the figure
Page 1/11
Wrong answer summary
D
Bad management and poorly maintained older ships.
LA
Question asked (563):
What shall you do if you see a person falling into the sea?
Selected answer (score 0):
Don't know
Correct answer:
Throw a lifebuoy over board and report to the bridge immediately.
Don't know
Correct answer:
CO2
Page 2/11
Wrong answer summary
D
Breadth is indicated by B, in the figure
LA
In the diagram, which letter is indicating the position "MIDSHIPS"?
Selected answer (score 0):
Don't know
Correct answer:
Midships is indicated by B, in the figure
Don't know
Correct answer:
A Gangway is a portable means of access between the ship and the shore
AR
Correct answer:
Legs bent, back straight, using leg muscles to lift
Page 3/11
Wrong answer summary
D
Inform the bridge of any new lights when they appear over the horizon or any other items
observed which may affect the ship
LA
Question asked (3942):
What is meant by the term "keeping a proper lookout" as applied to the bridge lookout?
Selected answer (score 0):
Don't know
Correct answer:
What will you do if you are helmsman and the OOW (officer on watch) gives you the
order: ”Starboard ten”
Selected answer (score 0):
G
Don't know
Correct answer:
Repeat the command back and then turn the wheel to make the rudder turn 10 degrees
N
to starboard of amidships
How will you act if you are helmsman and the OOW (officer on watch) gives you the
order: ”Nothing to port”
Selected answer (score 0):
Don't know
AR
Correct answer:
Don’t allow the ship to swing at all to port
watch) gives you the order to: "Change over from Automatic pilot to Hand steering".
Selected answer (score 0):
Don't know
Correct answer:
Apply the controls to disconnect the Automatic pilot and engage hand steering. Start
steering the vessel using the wheel and confirm with the OOW the change-over is
complete and the course you are to steer
Page 4/11
Wrong answer summary
Correct answer:
Not allow the clothes to be hung anywhere in the unmanned machinery spaces
D
Don't know
Correct answer:
60ºC
LA
Question asked (10168):
According to their physical state, extinguishing agents may be classified in to:
Selected answer (score 0):
Don't know
Correct answer:
Solid, liquid and gases
PA
Question asked (10262):
What is the main criterion generally taken into account to classify portable extinguishers:
G
Selected answer (score 0):
Don't know
Correct answer:
N
Correct answer:
The confined space always has six sides
Page 5/11
Wrong answer summary
D
2 sec
LA
Question asked (20231):
An inflatable lifejacket has:
Selected answer (score 0):
Don't know
Correct answer:
2 separate compartments
Correct answer:
All of the items specified in the alternative answers.
Page 6/11
Wrong answer summary
D
Secured via a weak link to a secure part of the ship
LA
Question asked (31563):
One of the checks during the annual Class survey of the UMS functions is focusing on
cleanliness of the engine room. What is the reason for such a check ?
Selected answer (score 0):
Don't know
Correct answer:
To reduce the general risk of fire in an unmanned engine room.
Don't know
Correct answer:
Remain in the expected location, available for immediate call from the bridge
Page 7/11
Wrong answer summary
D
There will be confusion as to whether or not containers are locked.
LA
On a Container vessel, fixed stacking cones are positioned:
Selected answer (score 0):
Don't know
Correct answer:
At the base of cell guides.
in:
Selected answer (score 0):
Don't know
Correct answer:
AR
Don't know
Correct answer:
Class 9 - Miscellaneous dangerous substances and articles
Page 8/11
Wrong answer summary
D
In a position separated by a complete compartment or hold from living quarters.
LA
On a Container vessel, containers containing marine pollutants are stowed:
Selected answer (score 0):
Don't know
Correct answer:
Under-deck.
Don't know
Correct answer:
No.
Page 9/11
Wrong answer summary
D
The Bridge is A, in the figure
LA
Is it always possible to use the word "ship" instead of the word "boat"?
Selected answer (score 0):
Don't know
Correct answer:
Normally a small vessel is called a "boat" rather than a "ship", otherwise it is not
important.
Don't know
Correct answer:
The respiratory centre in the brain
Page 10/11
Wrong answer summary
D
Halons
LA
The cargo manifold working platform surface should be made of:
Selected answer (score 0):
Don't know
Correct answer:
Open mesh grating
Don't know
Correct answer:
On the tank top mid-way in 40' guides to prevent transverse movement of 20' containers.
AR
Correct answer:
When the rubber washer is compressed and hardened.
Page 11/11
Wrong answer summary
CES version: CES 5.2.7
Test date: 13.03.2016
Test type: STCW
Department: Deck
Level: Support
Vessel type: Container vessel
D
LA
Question asked (514):
On the figure there are four (4) possible directions shown by the arrowed lines. Which
one would correctly shows the direction understood by the term "AFTER SPRING"?
Selected answer (score 0):
Don't know
Correct answer:
After spring is defined as A on the figure
What is name of the machine shown, used to heave on the ropes during mooring and
unmooring?
Selected answer (score 0):
Don't know
AR
Correct answer:
Winch
Page 1/11
Wrong answer summary
D
Towing spring
LA
Question asked (1485):
What is the correct understanding of the term "boat drill"?
Selected answer (score 0):
Don't know
Correct answer:
Don't know
Correct answer:
While altering the ships head, the instruction "steady as she goes" means reduce the
ships swing as rapidly as possible and steady on present course
Page 2/11
Wrong answer summary
D
Protective clothing, safety shoes, gloves, goggles, earmuffs.
LA
What is understood by the term "Boat Drill"?
Selected answer (score 0):
Don't know
Correct answer:
"Boat Drill" means the practical training in the various aspects of getting all the people
onboard safely off the ship, in the event of abandoning ship
sounded by the ship's whistle and alarm bells. What are you to do?
Selected answer (score 0):
Don't know
Correct answer:
AR
Don't know
Correct answer:
All of the mentioned equipment.
Page 3/11
Wrong answer summary
D
1 Smoking in bed. 2 Covering of electric fires with blankets. 3 Overloading electric plugs.
LA
If you detect a fire on board the ship, dependent on the situation, which of the following
actions is the first to be taken?
Selected answer (score 0):
Don't know
Correct answer:
Raise the fire alarm.
tasks to carry out. Which one of the listed tasks should be included in the watchman's
duties?
Selected answer (score 0):
Don't know
AR
Correct answer:
Check the moorings for correct tightness and ensure the gangway remains safe and
secure.
visibility, on the port side of the ship in a direction half way between right ahead and
abeam?
Selected answer (score 0):
Don't know
Correct answer:
The lookout should state "Light 4 points to port"
Page 4/11
Wrong answer summary
D
Regularly check the gyro against the magnetic compass
LA
How should you, as helmsman, give feedback to the OOW (officer on watch) that his
orders are understood?
Selected answer (score 0):
Don't know
Correct answer:
By repeating the order
BLEVE
Page 5/11
Wrong answer summary
D
Close the valves on both bottles, first the acetylene and then the oxygen bottle
LA
Question asked (10497):
Give the meaning of the following symbol
Selected answer (score 0):
Don't know
Correct answer:
Foam release station
Don't know
Correct answer:
4,50 m
Page 6/11
Wrong answer summary
D
8
LA
What is the minimum distance between the helmet and the head of the wearer supposed
to be?
Selected answer (score 0):
Don't know
Correct answer:
3 cm
Don't know
Correct answer:
Protect your ship from risks posed by security threats or incidents.
Page 7/11
Wrong answer summary
D
There will be confusion as to whether or not containers are locked.
LA
The function of a raised deck socket on a container vessel is:
Selected answer (score 0):
Don't know
Correct answer:
To house base twistlocks or stacking cones.
Don't know
Correct answer:
To link the top containers of adjacent stacks.
AR
Correct answer:
Reefer containers
Page 8/11
Wrong answer summary
D
Correct answer:
The ship being prosecuted.
LA
Question asked (33171):
Within the context of containerisation, Dangerous Goods are:
Selected answer (score 0):
Don't know
Correct answer:
Goods that are liable to cause damage to the ship.
Marine Pollutants
Don't know
Correct answer:
In a position separated by a complete compartment or hold from living quarters.
Page 9/11
Wrong answer summary
D
Guide or tag lines, tended from a safe location.
LA
Where is the "BRIDGE", in the figure?
Selected answer (score 0):
Don't know
Correct answer:
The Bridge is A, in the figure
Don't know
Correct answer:
Draught is D, in the figure
AR
Correct answer:
A deck crane using grabs.
Page 10/11
Wrong answer summary
D
Fractured spine
LA
The emergency oil pollution equipment locker must be:
Selected answer (score 0):
Don't know
Correct answer:
Prominently marked and easily accessible
Correct answer:
To prevent horizontal movement of 20'containers in 40' cell guides.
Page 11/11
Wrong answer summary
CES version: CES 5.2.8
Test date: 13.03.2016
Test type: STCW
Department: Deck
Level: Support
Vessel type: Container vessel
D
LA
Question asked (514):
On the figure there are four (4) possible directions shown by the arrowed lines. Which
one would correctly shows the direction understood by the term "AFTER SPRING"?
Selected answer (score 0):
Don't know
Correct answer:
After spring is defined as A on the figure
On the figure there are four (4) possible definitions of the term "AIR DRAUGHT" given.
Which one is the correct one?
Selected answer (score 0):
Don't know
AR
Correct answer:
Air draught is given by D on the figure
Page 1/11
Wrong answer summary
D
Winch
LA
Question asked (1485):
What is the correct understanding of the term "boat drill"?
Selected answer (score 0):
Don't know
Correct answer:
Don't know
Correct answer:
Those ship's personnel who have been assessed as competent and are duly authorised
to do so by the master as per the procedures as outlined in the ship's SMS system.
Page 2/11
Wrong answer summary
D
Get out of the engine room as soon as possible.
LA
Question asked (3610):
Which is the "QUAY", in the figure?
Selected answer (score 0):
Don't know
Correct answer:
The Quay is indicated by A, in the figure
Don't know
Correct answer:
Lee Side is the side that faces away from the wind
Page 3/11
Wrong answer summary
D
Correct answer:
Check the moorings for correct tightness and ensure the gangway remains safe and
secure.
LA
Question asked (3939):
If the relief for the bridge lookout does not appear at the end of the watch, when required,
what should be the actions of the existing lookout
Selected answer (score 0):
Don't know
Correct answer:
He should inform the Officer of the Watch and wait for instructions
PA
Question asked (3949):
If you are the helmsman on duty, what would be the correct action if the OOW (officer on
G
watch) gives you the order to: "Change over from Automatic pilot to Hand steering".
Selected answer (score 0):
Don't know
Correct answer:
N
Apply the controls to disconnect the Automatic pilot and engage hand steering. Start
steering the vessel using the wheel and confirm with the OOW the change-over is
complete and the course you are to steer
IA
order: “Port 20” and after a while the order: "Ease to 10"?
Selected answer (score 0):
Don't know
Correct answer:
Apply 20 degrees of rudder towards port and then after the second command reduce the
wheel to 10 degrees of helm.
M
Page 4/11
Wrong answer summary
Correct answer:
a solid (cardboard or wood…)
D
Don't know
Correct answer:
Sodium hydrosulphite , potassium hydroxide, magnesium
LA
Question asked (10204):
Which of the following measures should rather be considered as a prevention measure
than as a protection measure?
Selected answer (score 0):
Don't know
Correct answer:
Restriction in the usage of combustible materials
PA
Question asked (10264):
What are the main basic components of a portable extinguisher?
G
Selected answer (score 0):
Don't know
Correct answer:
N
Correct answer:
To connect the ship fire main to the shore lines
Page 5/11
Wrong answer summary
D
1 Min
LA
A lifejacket must not sustain burning or continue melting after being totally enveloped in a
fire for a period of:
Selected answer (score 0):
Don't know
Correct answer:
2 sec
Correct answer:
the "Abandon ship" signal is not specified, only the general emergency alarm signal is
stated
Page 6/11
Wrong answer summary
D
Nylon.
LA
Under what circumstances should gangway nets be rigged under the gangway?
Selected answer (score 0):
Don't know
Correct answer:
Whenever the gangway is rigged between ship and shore.
important?
Selected answer (score 0):
Don't know
Correct answer:
AR
Don't know
Correct answer:
Voyage itinerary and departure and arrival times.
Page 7/11
Wrong answer summary
D
Corner posts
LA
On a Container vessel, a vessel not carry left and right-handed twistlocks, because:
Selected answer (score 0):
Don't know
Correct answer:
There will be confusion as to whether or not containers are locked.
Don't know
Correct answer:
Connected to the ship's power supply and their setting temperatures verified.
AR
Correct answer:
Goods that are liable to cause damage to the ship.
Page 8/11
Wrong answer summary
D
Carrying dry cargoes prone to condensation
LA
As per IMDG Code, fishmeal not treated with anti-oxidant, would be carried on a
container vessel under:
Selected answer (score 0):
Don't know
Correct answer:
Class 4.2 - Flammable solid
containers is:
Selected answer (score 0):
Don't know
Correct answer:
AR
The master.
Page 9/11
Wrong answer summary
D
The Bridge is A, in the figure
LA
What is the meaning of "make fast"
Selected answer (score 0):
Don't know
Correct answer:
To secure a rope
Don't know
Correct answer:
Pinch soft part of the nose for 10 minutes while keeping the head forward over a basin
Page 10/11
Wrong answer summary
D
Halons
LA
The cargo manifold working platform surface should be made of:
Selected answer (score 0):
Don't know
Correct answer:
Open mesh grating
Don't know
Correct answer:
On the tank top mid-way in 40' guides to prevent transverse movement of 20' containers.
AR
Correct answer:
They must be clean and free of internal debris.
Page 11/11
Wrong answer summary
CES version: CES 5.2.7
Test date: 13.03.2016
Test type: STCW
Department: Deck
Level: Support
Vessel type: Container vessel
D
LA
Question asked (516):
On the figure there are four (4) possible definitions of the term "BOLLARD" given. Which
one is the correct one?
Selected answer (score 0):
Don't know
Correct answer:
Bollard is given by D on the figure
On the diagram, which letter indicates what is meant by the word "DRAUGHT" of the
ship?
Selected answer (score 0):
Don't know
AR
Correct answer:
Draught is indicated by D, in the figure
correct one?
Selected answer (score 0):
Don't know
Correct answer:
Head line is given by B on the figure
Page 1/11
Wrong answer summary
D
Ahead is given by A on the figure
LA
Question asked (571):
When could there be a demonstration of how to start a lifeboat engine?
Selected answer (score 0):
Don't know
Correct answer:
A demonstration could be arranged during a lifeboat drill
It is how many degrees of the compass a ship continues to turn after applying counter-
rudder
Page 2/11
Wrong answer summary
D
While altering the ships head, the instruction "steady as she goes" means reduce the
ships swing as rapidly as possible and steady on present course
LA
Question asked (1643):
What class of fire involves gas?
Selected answer (score 0):
Don't know
Correct answer:
Class C fire
Correct answer:
Lack of oxygen?
Page 3/11
Wrong answer summary
D
Lifeboat
LA
A class "D" fire involves what type of material?
Selected answer (score 0):
Don't know
Correct answer:
Metals
Correct answer:
Keeping a visual lookout all round the ship and also actively listening out for audio signals
Page 4/11
Wrong answer summary
D
Apply 20 degrees of rudder towards port and then after the second command reduce the
wheel to 10 degrees of helm.
LA
Question asked (10268):
Proteinic foams have the feature of being?
Selected answer (score 0):
Don't know
Correct answer:
PA
Of low expansion, viscous and solid, easily contaminated by hydrocarbons
In the fire fighting of fires of a type C with dry chemical powder extinguishers, the
application is performed
Selected answer (score 0):
Don't know
AR
Correct answer:
in a continuous way so that the powder spray is in the same direction as the one of the
flame
Page 5/11
Wrong answer summary
D
2 separate compartments
LA
You have abandoned ship in a liferaft. In most cases, which of the following actions
should you generally take?
Selected answer (score 0):
Don't know
Correct answer:
anchor
How many hand held distress flares are carried in each liferaft with SOLAS A pack?
Selected answer (score 0):
G
Don't know
Correct answer:
6
N
Which one of the following types of rope is the most dangerous to work with?
Selected answer (score 0):
Don't know
Correct answer:
AR
Nylon.
Don't know
Correct answer:
Whenever the gangway is rigged between ship and shore.
Page 6/11
Wrong answer summary
D
The water will explode into steam causing hot fat to be thrown far away thus possibly
causing severe burns or fire.
LA
Question asked (32019):
Which of these actions should crew take if a suspicious object that may be a bomb is
located during a search?
Selected answer (score 0):
Don't know
Correct answer:
PA
Confirm with their search partner that the object found is suspicious.
What are the duties of the "Standby Watch keeper" when he is not on the bridge?
Selected answer (score 0):
Don't know
Correct answer:
AR
Remain in the expected location, available for immediate call from the bridge
Don't know
Correct answer:
Damaged cell guides.
Page 7/11
Wrong answer summary
D
Corner posts
LA
On a Container vessel, fixed stacking cones are positioned:
Selected answer (score 0):
Don't know
Correct answer:
At the base of cell guides.
Connected to the ship's power supply and their setting temperatures verified.
Don't know
Correct answer:
Such provision has been provided for in the vessel's Cargo Securing Manual (CSM).
Page 8/11
Wrong answer summary
D
Under-deck.
LA
On a Container vessel, if you saw a stevedore starting to lash a container whilst other
containers were being stowed above it, you should?
Selected answer (score 0):
Don't know
Correct answer:
Tell him to wait until overhead containers have been stowed.
No.
Don't know
Correct answer:
Guide or tag lines, tended from a safe location.
Page 9/11
Wrong answer summary
D
To secure a rope
LA
What is the room often called where the crew eat their meals?
Selected answer (score 0):
Don't know
Correct answer:
The crew mess
Correct answer:
Cover the wound with a cloth
Page 10/11
Wrong answer summary
D
In refrigerated systems
LA
When lifting the container vessel’s hatch pontoons, you should stop the operation if the:
Selected answer (score 0):
Don't know
Correct answer:
Ship has an excessive heel.
Correct answer:
As tie down point for turnbuckles on deck or hatch cover.
Page 11/11
Wrong answer summary
CES version: CES 5.2.7
Test date: 13.03.2016
Test type: STCW
Department: Deck
Level: Support
Vessel type: Container vessel
D
LA
Question asked (518):
On the figure there are four (4) possible definitions of the term "BREADTH" given. Which
one is the correct one?
Selected answer (score 0):
Don't know
Correct answer:
Breadth is given by B on the figure
In the diagram, the depth of water under the keel is indicated by the letter "C". Which
bridge instrument would indicate this depth?
Selected answer (score 0):
Don't know
AR
Correct answer:
Echo Sounder
Page 1/11
Wrong answer summary
D
Portable bridge arrangement between ship and shore, when alongside.
LA
When acting as helmsman would you expect the reading of the gyro compass to be the
same as the magnetic compass?
Selected answer (score 0):
Don't know
Correct answer:
Very seldom would they be the same
Don't know
Correct answer:
CO2
Page 2/11
Wrong answer summary
D
Astern is indicated by D, in the figure
LA
In the diagram, which letter is pointing to the area of the ship known as the "STERN"?
Selected answer (score 0):
Don't know
Correct answer:
The Stern area is indicated by C, in the figure
Don't know
Correct answer:
Make Fast means secure the ropes to the bits
AR
Correct answer:
Lee Side is the side that faces away from the wind
Page 3/11
Wrong answer summary
D
Correct answer:
Outside the blue coloured zone.
LA
Question asked (3784):
Anyone of the crew who is assigned to watch duties in port has a number of important
tasks to carry out. Which one of the listed tasks should be included in the watchman's
duties?
Selected answer (score 0):
Don't know
Correct answer:
PA
Check the moorings for correct tightness and ensure the gangway remains safe and
secure.
Correct answer:
Inform the bridge of any new lights when they appear over the horizon or any other items
observed which may affect the ship
IA
What will you do if you are helmsman and the OOW (officer on watch) gives you the
order: ”Starboard ten”
Selected answer (score 0):
Don't know
Correct answer:
Repeat the command back and then turn the wheel to make the rudder turn 10 degrees
to starboard of amidships
Page 4/11
Wrong answer summary
Correct answer:
Regularly check the gyro against the magnetic compass
D
Don't know
Correct answer:
By repeating the order
LA
Question asked (10121):
The fire point is
Selected answer (score 0):
Don't know
Correct answer:
PA
The minimum temperature at which a combustible gives off vapours that may burn in
contact with oxygen in air, and at which combustion persists once the source of ignition
has been removed
G
Question asked (10158):
What kind of fuel will originate a class A fire?
Selected answer (score 0):
N
Don't know
Correct answer:
a solid (cardboard or wood…)
IA
Page 5/11
Wrong answer summary
D
Of low expansion, viscous and solid, easily contaminated by hydrocarbons
LA
Before extinction of an electric fire we need
Selected answer (score 0):
Don't know
Correct answer:
To disconnect the power source
Don't know
Correct answer:
2 sec
Page 6/11
Wrong answer summary
D
In the muster list.
LA
What material should boiler suits be made of?
Selected answer (score 0):
Don't know
Correct answer:
Cotton
Correct answer:
The individual wears bulky or out of season clothing.
Page 7/11
Wrong answer summary
D
Only if they have been approved and certified for this purpose.
LA
On a Container vessel, the purpose of a Bridge Fitting is:
Selected answer (score 0):
Don't know
Correct answer:
To link the top containers of adjacent stacks.
Don't know
Correct answer:
Check for cracks in tank top plating in areas where stack loads are transmitted.
AR
Correct answer:
Connected to the ship's power supply and their setting temperatures verified.
Page 8/11
Wrong answer summary
D
Such provision has been provided for in the vessel's Cargo Securing Manual (CSM).
LA
Question asked (33179):
The Maximum Securing Load (MSL) for a wire rope lashing connected to an eye plate by
means of a shackle is:
Selected answer (score 0):
Don't know
Correct answer:
On a Container vessel, the person responsible for the safe lashing and securing of
containers is:
Selected answer (score 0):
G
Don't know
Correct answer:
The master.
N
If your ship is in the tropics and you are going to be working out on deck during the day,
what is the recommended daily intake of water for you to avoid the effects of
dehydration?
Selected answer (score 0):
Don't know
AR
Correct answer:
4.5 litres.
(Hand signals as per the Code of Safe Working Practices for Merchant Seamen).
Selected answer (score 0):
Don't know
Correct answer:
Danger, or emergency stop!
Page 9/11
Wrong answer summary
D
Normally a small vessel is called a "boat" rather than a "ship", otherwise it is not
important.
LA
Question asked (33755):
What are the people probably doing in the picture?
Selected answer (score 0):
Don't know
Correct answer:
The people are hosing down the cargo hold to clean it.
Correct answer:
Mouth, nose and throat
Page 10/11
Wrong answer summary
D
Low sulphur fuels reduce emissions of volatile organic compounds
LA
When lifting the container vessel’s hatch pontoons, you should stop the operation if the:
Selected answer (score 0):
Don't know
Correct answer:
Ship has an excessive heel.
Don't know
Correct answer:
On deck.
AR
Correct answer:
To prevent horizontal movement of 20'containers in 40' cell guides.
Page 11/11