Professional Documents
Culture Documents
Conplast CN
Conplast CN
Conplast CN should be used to meet the addition levels As with all structural concrete, good curing practice should be
required in concrete mix specification documents. Typical maintained. Water spray, wet hessian or a Concure spray
specified dosage levels are normally in the range of 7.5 to 22.5 applied curing membrane should be used.
litres per cubic metre of concrete. Because Conplast CN has
a high dosage level, calculation of water : cement ratio should Limitations
include the water added to the mix in the admixture. Conplast CN may accelerate the set of concrete. Trial mixes
will determine any such effect. Various grades of Conplast
Properties retarding admixtures can be used to offset any undesired
effects.
Appearance: Pale straw coloured liquid
Chloride content: Nil to BS 5075
Calcium Nitrite content: Minimum 30%
Conplast CN
Estimating Precautions
Conplast CN is available in 210 litre drums or bulk supply. Health and safety
Fosroc Jordan
P. O. Box 253
King Abdullah II Industrial Estate
Sahab 11512 Jordan
Tel : 5359562 Fax : 5359563
Factory Tel : 4022665
Important note
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard terms and conditions of sale, copies of which
may be obtained on request. Whilst Fosroc endeavours to ensure that any advice, recommendation, specification or information it may give is accurate and correct,
it cannot, because it has no direct or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from
the use of its products, whether or not in accordance with any advice, specification, recommendation or information given by it.
www.fosroc.com JOR/08/2000