Professional Documents
Culture Documents
Method Statement For Modification of Actuator's Base Plate - Rev01
Method Statement For Modification of Actuator's Base Plate - Rev01
Method Statement For Modification of Actuator's Base Plate - Rev01
: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
PROJECT:
METHOD STATEMENT
Sections changed in last revision are identified by a vertical line in the margin.
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
1
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
C
An extra plate will be cut and drilled
according to the size and location of the
anchor bolt and welded to the base
support. The material of the plate shall be
S275JR or equivalent with 20mm
thickness.
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
3
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
An extra
plate will be
cut and
drilled
according to
G the size and
location of
the anchor
This section bolt and
will be cut to welded to
the end and the base
removed support.
An extra
plate will be
cut and
drilled
according to
the size and
I location of
the anchor
bolt and
welded to
the base
support.
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
5
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
M
This section will New plate with the size same
be cut to the with the previous cut length
end and is welded to the base support
removed
1
This section will
be cut to the New plate with the size same
end and with the previous cut length
removed is welded to the base support
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
3 OK
4 OK
7
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
An extra plate
will be cut
and drilled
according to
the size and
7 location of
the anchor
This section will bolt and
be cut to the welded to the
end and base support.
removed
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
8 OK
An extra plate
will be cut
and drilled
9 according to
the size and
location of
the anchor
This section will bolt and
be cut to the welded to the
end and base support.
removed
9
Doc. No.: JPS/LB/04
METHOD STATEMENT
Issue No.: 01
An extra plate
will be cut
and drilled
according to
14 the size and
location of
the anchor
This section will bolt and
be cut to the welded to the
end and base support.
removed
11