Professional Documents
Culture Documents
Remedy For Cols
Remedy For Cols
Remedy For Cols
Using MasterInject 1315 from BASF as low viscosity epoxy resin or equivalent
Identify and mark the cracks.
Remove all grease, oil, dust, residual curing compound, mould release agent or other contaminant
that could impair adhesion of the injection ports.
Close the cracks with epoxy putty to a band width of about 10cm (i.e 5 cm on each side of the
crack).
Install flat packers at a distance of 20-50cm using epoxy putty (MasterBrace ADH 2200
Inject a two part solvent free low viscous, epoxy injection resin MasterInject 1315 into the cracks
by using a high-pressure electric injection machine. The injected resin will fill the cracks completely
and will bond them permanently. (Inject from the lowest point or furthest point towards the center
checking for resin coming out of the next hole along).
The next day i.e. after 24 hours, remove the packers and the epoxy putty and reprofile the holes.
Patch Repair for areas below 200x200mm and depth less than 40 mm