Professional Documents
Culture Documents
ME303B
ME303B
ME303B
(b) Suggest suitable materials for the (b) A cotter joint is used to connect two
following giving reasons for their choice : rods of square cross-section and is
subjected to tensile load of 50 kN. Use
(i) rivet
d = 120 N/mm2 and d = 75 N/mm2
(ii) lathe bed and the strength in compression can be
taken as twice the strength in tension.
(iii) friction lining
Design the strap (fork) end of the joint
(iv) flywheel such that the load carrying capacity is
almost 1.25 times the external load in all
(v) keys for shaft and hub.
possible modes of failure.
M-E-32 2 (3-14/7) M-E-32 3 P.T.O.
8. (a) Dfferentiate between : 5+10 6. Design a flywheel for a four stroke internal
(i) Short shoe and long shoe brakes combustion engine developing 45 kW at
(ii) Fixed shoe and pivoted brakes.
200 rpm with 100 explosions per minute. The
(b) A short shoe external drum brake is
total fluctuation of speed is limited to 0.5% of
shown in Figure P8 has 40 mm width,
coefficient of friction 0.23 and pmax = 900 the mean on either side. The work done during
kPa. Determine : the working stroke is 1.4 times the work done
(i) The limiting force F that can be during the cycle. Assume that the flywheel
applied to the lever
stores (16/15) times the energy stored by the
(ii) Braking torque
rim and the rim section having width 4 times
(iii) Radial force on the lever pivot
the depth so that the hoop stress does not
(iv) Whether the brake is self-energizing
or de-energizing for the direction exceed 4.5 N/mm2. The density of the material
of rotation involved. is 7200 kg/m3. 15
F=? Unit IV
250 mm 320 mm
7. (a) Differentiate between dry and wet clutch
design. 5+10
240 mm (b) Design a centrifugal clutch to transmit
150 mm
18 kW at 700 rpm. Take inside radius of
the pulley rim to be 150 mm. Clearly
400 mm
state all the design decisions taken by
Fig. P8
you.