I Year-CSE Department of Mechanical Engineering Duration – 90 Minutes
GE8152 Engineering Graphics Unit test - 1 Total marks=50 Part A 2x20 = 40 1.(a) Construct an Ellipse for the eccentricity value equal to 2/3 and the distance between the vertex and focus is 30mm. Draw the tangent and normal at any point on the curve. (or) (b) Draw the hyperbola curve when the distance between the Directrix and focus 50 mm and the eccentricity is 3/2. Draw the tangent and normal at any point on the curve. 2.
(or)
3. Draw the projections of following Points 1x10 = 10
a) P is 30mm behind VP and 20mm below HP b) Q is 45mm above HP and 15mm infront of VP c) R is on HP and VP d) S is on HP and 40mm infront of VP e) T is 25 mm infront VP and 10 mm below HP
Government College of Engineering Srirangam
I Year-CSE Department of Mechanical Engineering Duration – 90 Minutes GE8152 Engineering Graphics Unit test - 1 Total marks = 50 Part A 2x20 = 40 1.(a) Construct an Ellipse for the eccentricity value equal to 2/3 and the distance between the vertex and focus is 30mm. Draw the tangent and normal at any point on the curve. (or) (b) Draw the hyperbola curve when the distance between the Directrix and focus 50 mm and the eccentricity is 3/2. Draw the tangent and normal at any point on the curve. 2.
(or)
3. Draw the projections of following Points 1x10 = 10
a) P is 30mm behind VP and 20mm below HP b) Q is 45mm above HP and 15mm infront of VP c) R is on HP and VP d) S is on HP and 40mm infront of VP e) T is 25 mm infront VP and 10 mm below HP