Professional Documents
Culture Documents
Installation Guide
Installation Guide
Installation Guide
Installation of this equipment should only be performed by skilled personnel such as The following information is a list of basic steps required to install an XW Inverter/Charger.
Actual installation procedures will vary depending upon the configuration of the intended
qualified electricians and Certified Renewable Energy (RE) System Installers. system.
120/240 Vac or
240 Vac only
Inverting Inverting
Flashing = sell Flashing = sell
Gen (AC2) Gen (AC2)
Fault / Fault /
Charging Charging
Warning Warning
Equalize Equalize
Battery Battery
24 Vdc or 48 Vdc
Or….
Or….
4 5
1 2
3 4
Or…. Or….
Or….
2 4b
3
5
2 4b Or….
Or….
3 5
Grid
(AC1)
Inverting
Gen Flashing =
(AC2) sell
Fault /
Charging
Warning
Equalize
Battery
Hybrid
Hybrid Inverter/Charger
Inverter/Charger
xantrex
AC LEGEND
Grid (AC1)
Fault /
Charging
Warning
Equalize
Battery
HOT L1
NEUTRAL
L1 L2
HOT L2
Ground
AC OUT AC IN AC IN
GROUND L1 N L2 L1 N L2 L1 N L2
Hybrid Inverter/Charger
(+) (–)
(+)
ON
(–)
L1 L2
OFF
G N
Fuse Block
BATTERY
LEGEND
FUSE
FUSE
CLASS TT
CLASS
Negative (–)
Negative (–)
Positive (+)
Positive (+)
24 Vdc or 48 Vdc
xantrex
Ground
975-0238-01-01 Rev A.vsd/SI Wiring(7)/April 24, 2007
© 2007 Xantrex Technology Inc.
xantrex
Grid
(AC1) Invertin
g
Gen Flashin
(AC2) g = sell
Fault /
Chargin
Warnin
g
g
Equaliz
e Battery
xantrex
XWBAT
BA Solar Charge
PV PV Controller
T+ – – +
XW Conduit Box
Battery Bank
Vented Battery
AC LEGEND Grid
(AC1)
Gen
Inverting
Flashing
(AC2) = sell
Fault / Chargin
Warning g
AC Breakers
AC Breakers (See Note 1)
Neutral Equalize
Battery
HOT L1 xantrex
xantrex
HOT L2
Ground
BAT BAT PV PV
+ – – +
PV + BAT + PV – BAT –
(–)
AC OUT AC IN AC IN
L1 N L2 L1 N L2 L1 N L2
Mppt PV
DC Disconnects
Hybrid Inverter/Charger
L1 L2
(+) (–) G N
DC LEGEND
Negative (–)
120/240 Vac or
240 Vac only
Positive (+)
Ground
BTS Communication
Cable
If no Grid is available,
BATTERY
the generator can be
LEGEND
connected to the AC breakers
All configurations must comply with local and national in the XW Power Distribution
electrical code jurisdiction. Consult your local certified Panel, instead of to a separate
Negative (–) AC breaker.
installer or local electrical authority to ensure compliance.
C-Series
xantrex
Grid
(AC1) Invertin
g
Gen Flashing
(AC2) = sell
Fault / Chargin
Warning g
Equaliz
e Battery
DC In
XW Conduit Box
Vented Battery
All configurations must comply with local and national
975-0238-01-01 Rev A.vsd/SI RE DL(10)/April 24, 2007
Enclosure
electrical code jurisdiction. Consult your local certified
© 2007 Xantrex Technology Inc.
installer or local electrical authority to ensure compliance.
L1 L2
G N
XW Inverter/Charger
Communication Ports
CM/CMR BTS
xantrex
INV 1 GEN
Bypass INV 1 OUT
IN
AC LEGEND
Neutral
HOT L1 (–)
HOT L2
AC OUT AC IN AC IN
Inv
Ground OUT
Grid GEN DC Disconnect
L1 N L2 L1 N L2 L1 N L2
Mppt PV
Hybrid Inverter/Charger
All configurations must comply with local and national If no Grid is available, the generator
electrical code jurisdiction. Consult your local certified can be connected to the AC breakers in the
installer or local electrical authority to ensure compliance. XW Power Distribution Panel, instead of to a
separate AC breaker.
Grid Grid
(AC1) Invertin (AC1) Invertin
g g
Gen Flashin Gen Flashin
(AC2) g = sell (AC2) g = sell
Fault / Fault /
Chargin Chargin
Warnin Warnin
g g
g g
Equaliz Equaliz
e Battery e Battery
xantrex
+
XW Solar
BAT BAT
–
PV PVCharge Controller
– +
xantrex
XW Solar
BAT BATPV PVCharge Controller
+ – – +
975-0238-01-01 Rev A.vsd/DI RE Solar(12)/April 24, 2007 All configurations must comply with local and national
© 2007 Xantrex Technology Inc. Vented Battery
Enclosure
electrical code jurisdiction. Consult your local certified
installer or local electrical authority to ensure compliance.
L1 L2
AC LEGEND N
xantrex xantrex XW Solar
Charge
Neutral Controller
INV 1 IN INV 2 IN Grid Grid INV 1 OUT INV 2 OUT INV 1 IN INV 2 IN
(Grid) (Grid) Bypass Bypass (AC Loads) (AC Loads) (Gen) (Gen)
HOT L2 Inverter AC
xantrex Distribution
Ground Panel
NEUTRAL
L1 L2
BAT BAT PV PV
+ – – +
(–)
AC OUT AC IN AC IN AC OUT AC IN AC IN
DC
L1 N L2 L1 N L2 L1 N L2 L1 N L2 L1 N L2 L1 N L2
Mppt PV
Disconnects
CC CC PV
+
PV GROUND
+ + +
xantrex
BAT BAT PV PV
+ – – +
DC LEGEND
BATTERY
LEGEND Negative (–)
C-Series C-Series
xantrex xantrex
Inverting Inverting
Flashing = sell Flas hing = sell
Fault / Fault /
Charging Charging
Warning Warning
Equalize Equalize
Battery Battery
DC In
XW Conduit Box XW Conduit Box
975-0238-01-01 Rev A.vsd/DI RE DL(14)/April 24, 2007 All configurations must comply with local and national
© 2007 Xantrex Technology Inc.
electrical code jurisdiction. Consult your local certified
installer or local electrical authority to ensure compliance.
L1 L2
G N
N
xantrex xantrex
Grid (AC1)
Inverting
Flashing = sell
Gen (AC2)
Fault /
Charging
Warning
Equalize
AC Breakers (See Note 1)
Battery
INV 1 IN INV 2 IN Grid Grid INV 1 OUT INV 2 OUT INV 1 IN INV 2 IN
(Grid) (Grid) Bypass Bypass (AC Loads) (AC Loads) (Gen) (Gen)
(–)
AC OUT AC IN AC IN AC OUT AC IN AC IN
L1 N L2 L1 N L2 L1 N L2 L1 N L2 L1 N L2 L1 N L2
Mppt PV
DC Disconnects
BTS Communication
Cable
Vented Battery
Enclosure
975-0238-01-01 Rev A.vsd/DI RE DL Wiring(15)/April 24, 2007 Battery Temperature
Sensor (BTS)
© 2007 Xantrex Technology Inc.