If Vin is the input supply voltage applied to a pushpull
converter, then voltage withstanding capability of the controlled power semiconductor switches should be atleast Ans: (b) 2*Vin (x)
2. In a pushpull converter, the secondary to primary turns
ratio is 3. The input supply voltage is 10V. If the output voltage is 10V, then the duty ratio is (duty ratio is defined w.r.t the pole voltage waveform) Ans: (a) 1/3 (x)
3. In a pushpull converter, the secondary to primary turns
ratio is 3. The input supply voltage is 10V. The PIV rating for the diodes should be atleast Ans: (d) 60V (x)
4. In a half bridge converter, the primary side switches are
switched at 20kHz. The frequency of the currrent ripple in the inductor is Ans: (c) 40kHz (x)
5. In a full bridge converter, 40V battery is supplying a 16V
load at 2A. The switches are operating at 20kHz and a ON time of 20us. The secondary to primary turns ratio for the bridge transformer is Ans: (a) 0.5 (x)
6. The voltage rating of the controlled power semiconductor
switches of a half bridge converter supplied from a 48V battery is Ans: (b) 48V (x)
7. In a dc-dc converter that is operated in close loop, the
controller is a proportional controller. The steady state error is Ans: (c) finite value (x)
8. In a dc-dc converter that is operated in close loop, the
controller is a Integral controller. The steady state error is Ans: (b) zero (x)
9. In a multi-output flyback converter, one of the secondary
windings delivers power to a 15V, 1A load from a 24V supply. The secondary to primary turns ratio is 2. A three terminal linear regulator is used to interface the output of the converter to the load. The minimum allowable drop across the regulator is 3V. The operating duty ratio is Ans: (c) 0.2727 (x) 10. In a multi-output flyback converter, one of the secondary windings delivers power to a 15V, 1A load from a 24V supply. The secondary to primary turns ratio is 2. A three terminal linear regulator is used to interface the output of the converter to the load. The minimum allowable drop across the regulator is 3V. The secondary power rating is Ans: (b) 18W (x)