Professional Documents
Culture Documents
2-Bromo-1-Phenyl-1-Pentanone MSDS
2-Bromo-1-Phenyl-1-Pentanone MSDS
2-Bromo-1-Phenyl-1-Pentanone MSDS
2-Bromo-1-Phenyl-1-Pentanone
no data available
1-9
AECO HOLDING LIMITED
XIAMEN AECO CHEMICAL INDUSTRIAL CO.,LTD.
Add:No 611 Sishui Road,Huli,Xiamen,China 361009
Tel:+86 592 599 8717 Fax:+86 592 555 4527
__________________________________________________________________________________
Other hazards which do not result in classification
no data available
General advice
Consult a physician. Show this safety data sheet to the doctor in attendance.
If inhaled
If breathed in, move person into fresh air. If not breathing, give artificial respiration.
Consult a physician.
Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician.
If swallowed
Never give anything by mouth to an unconscious person. Rinse mouth with water. Consult
a physician.
no data available
no data available
Extinguishing media
no data available
Use personal protective equipment. Avoid dust formation. Avoid breathing vapours, mist or
gas. Ensure adequate ventilation. Evacuate personnel to safe areas. Avoid breathing dust.
For personal protection see section 8.
Environmental precautions
Prevent further leakage or spillage if safe to do so. Do not let product enter drains.
Discharge into the environment must be avoided.
Pick up and arrange disposal. Sweep up and shovel. Keep in suitable, closed containers for
disposal.
Avoid contact with skin and eyes. Avoid formation of dust and aerosols. Avoid exposure -
obtain special instructions before use.Provide appropriate exhaust ventilation at places
where dust is formed. For precautions see section 2.2.
Store in cool place. Keep container tightly closed in a dry and well-ventilated place.
3-9
AECO HOLDING LIMITED
XIAMEN AECO CHEMICAL INDUSTRIAL CO.,LTD.
Add:No 611 Sishui Road,Huli,Xiamen,China 361009
Tel:+86 592 599 8717 Fax:+86 592 555 4527
__________________________________________________________________________________
Control parameters
no data available
no data available
Handle in accordance with good industrial hygiene and safety practice. Wash hands before
breaks and at the end of workday.
Eye/face protection
Safety glasses with side-shields conforming to EN166. Use equipment for eye protection
tested and approved under appropriate government standards such as NIOSH (US) or EN
166(EU).
Skin protection
Wear impervious clothing. The type of protective equipment must be selected according to
the concentration and amount of the dangerous substance at the specific workplace.
Handle with gloves. Gloves must be inspected prior to use. Use proper glove removal
technique(without touching glove's outer surface) to avoid skin contact with this product.
Dispose of contaminated gloves after use in accordance with applicable laws and good
laboratory practices. Wash and dry hands. The selected protective gloves have to satisfy
the specifications of EU Directive 89/686/EEC and the standard EN 374 derived from it.
Respiratory protection
Thermal hazards
no data available
4-9
AECO HOLDING LIMITED
XIAMEN AECO CHEMICAL INDUSTRIAL CO.,LTD.
Add:No 611 Sishui Road,Huli,Xiamen,China 361009
Tel:+86 592 599 8717 Fax:+86 592 555 4527
__________________________________________________________________________________
Physical state no data available
Colour no data available
Odour no data available
Melting point/ freezing pointno data available
Boiling point or initial boiling282.267ºC at 760 mmHg
point and boiling range
Flammability no data available
Lower and upper explosion no data available
limit / flammability limit
Flash point 42.513ºC
Auto-ignition temperature no data available
Decomposition temperature no data available
pH no data available
Kinematic viscosity no data available
Solubility no data available
Partition coefficient no data available
n-octanol/water (log value)
Vapour pressure no data available
Density and/or relative 1.31g/cm3
density
Relative vapour density no data available
Particle characteristics no data available
Reactivity
no data available
Chemical stability
no data available
Conditions to avoid
no data available
Incompatible materials
Acute toxicity
Skin corrosion/irritation
no data available
no data available
no data available
no data available
Carcinogenicity
no data available
Reproductive toxicity
no data available
STOT-single exposure
no data available
STOT-repeated exposure
no data available
Aspiration hazard
no data available
6-9
AECO HOLDING LIMITED
XIAMEN AECO CHEMICAL INDUSTRIAL CO.,LTD.
Add:No 611 Sishui Road,Huli,Xiamen,China 361009
Tel:+86 592 599 8717 Fax:+86 592 555 4527
__________________________________________________________________________________
Toxicity
no data available
Bioaccumulative potential
no data available
Mobility in soil
no data available
no data available
Disposal methods
Product
Contaminated packaging
Containers can be triply rinsed (or equivalent) and offered for recycling or reconditioning.
Alternatively, the packaging can be punctured to make it unusable for other purposes and
then be disposed of in a sanitary landfill. Controlled incineration with flue gas scrubbing is
possible for combustible packaging materials.
7-9
AECO HOLDING LIMITED
XIAMEN AECO CHEMICAL INDUSTRIAL CO.,LTD.
Add:No 611 Sishui Road,Huli,Xiamen,China 361009
Tel:+86 592 599 8717 Fax:+86 592 555 4527
__________________________________________________________________________________
UN Number
Environmental hazards
no data available
Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
no data available
Safety, health and environmental regulations specific for the product in question
The information above is believed to be accurate and represents the best information
currently available to us. However, we make no warranty of merchantability or any other
warranty, express or implied, with respect to such information, and we assume no liability
resulting from its use. Users should make their own investigations to determine the
suitability of the information for their particular purposes. In no event shall Aeco be liable
for any claims, losses, or damages of any third party or for lost profits or any special,
indirect, incidental, consequential or exemplary damages, howsoever arising, even if
Fisher has been advised of the possibility of such damages.
9-9