The document provides instructions for modifying various connector types and part numbers. It describes filing off connector corners, swapping wires, modifying base plates, and cutting pins flush with guide rails for different PCU and component combinations.
The document provides instructions for modifying various connector types and part numbers. It describes filing off connector corners, swapping wires, modifying base plates, and cutting pins flush with guide rails for different PCU and component combinations.
The document provides instructions for modifying various connector types and part numbers. It describes filing off connector corners, swapping wires, modifying base plates, and cutting pins flush with guide rails for different PCU and component combinations.
MP B223 B223 File corner off C2000 2042 2042 connector MP B223 B223 """" C2500 2042 2042 MP B223 B223 """" C2500 2042 2042 MP B223 B223 File corner off C3500 2042 2042 connector MP B223 B223 """" C4500 2042 2042 MP D029 D029 File corner off C2800 2256 2256 connector MP D029 D029 and swap wires C3300 2256 2256 over MP D029 D029 File corner off C4000 2256 2256 connector MP D029 D029 and swap wires C5000 2256 2256 over MP D089 D029 File corner off C3001 2250 2256 connector MP D089 D029 and swap wires C3501 2250 2256 over Also mod base plate MP D089 D029 File corner off C4501 2250 2256 connector MP D089 D029 C5501 2250 2256 and swap wires Lift plastic tab (1) with knife edge or small tip screwdriver and pull wire out . Now swap it over with the wire in the second position (2) using MP D144 D029 the same method. Next, crimp the plastic tab back down with needle nose pliers. Gently tug C4502 2250 2256 on the wire to make sure they are secure. MP D144 D029 Also mod base C5502 2250 2256 plate Cut the pin in the rear of the machine so it is flush with the top of the PCU's guide rail.