Professional Documents
Culture Documents
HHG (Orgonite Holy Hand Grenade) Tutorial
HHG (Orgonite Holy Hand Grenade) Tutorial
HHG (Orgonite Holy Hand Grenade) Tutorial
Wizzers Desk INFO MAIN Personal Bioenergy Tools - Orgone Matrix Material Ergonite Orgonite Organite - Construction
info & sales- Radionics Stations -Mobius Coils - EM Pollution Control - DIY Plans & More! - Site Map / Products / Info / Ebooks /
Contact / Legal / Links / Orgonite / Radionics
Note: While there are many other suitable vessels which could serve as mold for this device, I have
used a plastic funnel for this example as it is readily available in most places and relatively durable. In
any case, the same technique of construction applies regardless of the container used for a mold,
which can be in the shape of a pyramid, cone, cylinder or hemisphere, so long as it has a volume at
least great that of a as a cone 4" wide x 4" tall. Presently, pyramids and cones are the shape this device
is most often built in.
1. - Cut the tip off of the funnel and tape over the hole at the
small end of the funnel with aluminum tape (preferable) or
parcel tape. Electrical tape, duct tape & masking tape do not
work as well for this as aluminum tape. In some way, plug the
hole so that the resin does not leak out.
2. - Sit the funnel in the jar so that it is upright and more or less
level.
Mix enough resin and catalyst (be sure to mix well, min. 1
minute of mixing) to come up level with the surface of the metal
filings. Pour the resin in and let it run down into the metal filings.
Gently shake or tap the mold to release bubbles.
6. - Put in some more metal particles, enough to fill the mold
about 1/2 to 2/3 full.
metal. The layer of resin only should be about 1/4" thick. Take a
moment to adjust the molds so that they are more or less level
at this point.
11. - Remove the molds from the jars, turn them upside down,
and give them a smack to release the brand new HHG you just
made. If the mold sticks, you can either use a thin bladed knife
to push in between the mold and the resin, or you can try
spraying penetrating oil around the edges where the mold meets
the resin. Dropping it on the floor sometimes works, but
sometimes it breaks the resin.
This is all the info you need to get started making fully functional basic HHGs. Please feel free to make copies of, re-post
on your own site, save on your hard drive, print and/or distribute this page freely, so long as the page is reproduced in it's entirety
and unaltered, including all links embedded therein.