Professional Documents
Culture Documents
CT 990
CT 990
› INSTRUCTION GUIDE
SPECIAL FEATURES
10W
Ultra high IP67 Dead man
output power certified function
Main features 2
Main controls and parts of the radio 3
Radio buttons 3
LCD Display 5
Troubleshooting 22
Technical specifications 23
Maintenance
Your Two Way Radio is an electronic product of exact design and should be
treated with care.
The suggestions below will help you to fulfill any warranty obligations and to
enjoy this product for many years.
• Do not attempt to open the unit. Non-expert handling of the unit may
damage it.
• Do not store the Radio under the sunshine or in hot areas. High tempe-
ratures can shorten the life of electronic devices, and warp or melt certain
plastics.
• Do not store the radio in dusty and dirty areas.
• Keep the Radio dry. Rainwater or damp will corrode electronic circuits.
• If it appears that the Radio diffuses peculiar smell or smoke, please shut off
its power immediately and take off the charger or battery from the Radio.
• Do not transmit without antenna.
• Do not use detergents, alcohol, solvents or abrasives to clean the radio. Just
use a soft clean cloth.
1
CT990 CT990
Menu Menu
1. Antenna
2. Encoder: rotate it to select the desired channel
3. Power / Switch / Volume control: Rotate to turn on/off CT990 and to
adjust the volume
4. Led: transmission (red) / reception (green)
5. LCD Display
6. Microphone
7. < Back: press to exit the Menu and functions. A/B (appears on the di-
splay): push to select the desired frequency (VHF or UHF) in the main
or secondary display.
Menu list
The Menu list can change depending on the mode you selected.
Some functions are included in channel mode only; they will be described at
the end of this chapter.
Procedure:
with the radio switched off, keep pressed PTT and Menu at the same time and
turn it on.
Press Menu to enter the DATA-RESET section. The 3 possible options will be
displayed: FULL, VFO, CH.
Select the desired type of reset and push Menu. Push it again for confirmation.
Battery recharge doesn’t last The battery pack is over. Change it with a
long new one. Battery pack is not completely
charged.
Reception led turns on but no Make sure the volume is not too low.
sound heard Make sure to have the same CTCSS and
DCS codes of your group
The keypad doesn’t work Keypad lock function hasn’t been enabled
WARNING: Direct plug-in ac/dc power supply must be used for disconnecting the
transceiver from the mains; the desktop charger must be positioned close to the
unit and easily accessible.
All articles displaying this symbol on the body, packaging or instruction manual
of same, must not be thrown away into normal disposal bins but brought to
specialised waste disposal centres. Here, the various materials will be divided
by characteristics and recycles, thus making an important contribution to en-
vironmental protection.
Alle Artikel, die auf der Verpackung oder der Gebrauchanweisung dieses
Symbol tragen, dürfen nicht in den normalen Mülltonnen entsorgt werden,
sondern müssen an gesonderten Sammelstellen abgegeben werden. Dort wer-
den die Materialien entsprechend ihrer Eigenschaften getrennt und, um einen
Beitrag zum Umweltschutz zu liefern, wiederverwertet.