Big Rubber Gasket for STEP1 Small Rubber Gasket for STEP2
STEP1:Install the Rack Body
Two Big Rubber Gasket
Slightly tighten it up, and the
rack can’t easily rotate STEP2:Install the Reflector
Install the Reflector.
STEP3:Adjust the Panel of Rack Body to the
suitable position. Adjust Panel Position
Loosen the two screws, and adjust
the Panel of Rack Body to the suitable position you need. STEP4:Install the two Supporting Bars
Disassemble the Supporting Bar
into three parts
Small Solid Bar
Bracket
Big Hollow Bar
Two Small Rubber Gasket
Install the Bracket. Slightly tighten both
Attention! Keep the transmission screws, and they can’t easily move. cable or the brake cable out of the Bracket, so it can work ok. Install the Small Solid Bar. Slightly tighten the screw, and the bar can rotate easily.
Install the Big Hollow Bar. Slightly
tighten the screw, and the bar can rotate easily.
After this step, tighten up all the screws on this rack!