Professional Documents
Culture Documents
Power Grid Question 2015
Power Grid Question 2015
Power Grid Question 2015
60 k-ft
4’ 6’
*Find the Maximum Shear Stress in a rectangular Cross-Section of 6”x12” to a vertical Shear force of 48
kip.
12”
6”
*Determine the Allowable Axial Compressive force for a 12”x18” column section Reinforced with 10-3/4”
18”
10-3/4”Φ3 bars
12”
*Calculate the diameter of a Circular Pile that Discharge 2.5cfs water with a velocity of 6fps?
* What are the factors determining the per capita water consumption rate?
* For a Arial Photography determine number of Flight lines from the following data:
Area : 16x20miles
Focal Length :12”
Photograph Size : 9”x9”
Photograph Scale : 1:10000
Sidelap :25%
Overlap :60%
Flight lines in the direction of 20 miles & the outer lines coincide with the boundaries.
*Draw the Schematic Relationship between access and movement function of streets.
*Draw the Qualitative Test Property curves for Hot-Mix design data by Marshall Method?
*Calculate the Angularity number for the aggregate sample from the factor data:
*A Nine Pile group consisting a 18inch Diameter concrete piles was cast-in-situ in a Clayey soil whose
unconfined compressive strength is 100 Ib/ft2.Each pile in 60’ long and the pile spacing is 2.5 times the
pile diameter. Using a reduction factor α=0.5 and Factor of safety=3. Calculate Allowable Skin Friction of
single pile.
*Sieve Analysis were performed for a course sand and it has been found that 100% of the sample
retained on No.30 sieve. What is value of fineness modulus of the sample?
*In its natural state a moist soil has a volume of 0.4ft3 and weighs 50Ib the oven dry weight of the soil is
40Ib. Calculate the bulk unit weight, dry unit weight & moisture Content of soil.
* Calculate the settlement of a 2.5m deep clay layer due to an increase of 30kn/m2, Pressure at the mid-
height the layer. Given, Effective Vertical Stress at the Mid-height of the layer=30kn/m2 Given, ℮ =0.8 &
cc=0.28
* A Sample of dry Sand was tested in a direct share supported………The sample failed under a shearing
load of 58lb.The sample was 2” by 2”….Calculate the angle of Internal friction of the sand sample??