Professional Documents
Culture Documents
Electronics Manual
Electronics Manual
VOLTAGE DOUBLERS
Introduction:
Objectives:
Materials / Equipment:
1
Diagram:
Fuse 470 D2
C1
AC
D1 C2 470 1K
Plug
CT
Fuse
470
AC
Plug 1K
CT
470
Procedure:
2. In fig. 7-1, assume the rms secondary voltage of 12.6 V. Calculate and record
the quantities listed in Table 7-2. Use the equation for peak-to-peak ripple.
B. Full-wave doubler
2
5. Repeat steps 2 through 4 for the full-wave doubler of fig. 7-2. Use Table 7-3 to
record your data. When calculating the peak-to-peak ripple, noticed that the
load resistors is in parallel with two capacitors in series.
C. Troubleshooting
8. Connect the circuit of fig. 7-1 with foregoing trouble. Measure and record the
quantities of Table 7-4.
Rpri
Rsec
3
Table 7-3. Full-wave doubler
Calculated Measured
VDC fout Vrip VDC fout Vrip
Open C1
Open D2
Open C2
4
POST-TEST
I. Encircle the letter of the corresponding correct answer among the choices.