Professional Documents
Culture Documents
OSHA 10 Construction Final Exam Answer Key Occupational Safety and Health Administration Safety PDF
OSHA 10 Construction Final Exam Answer Key Occupational Safety and Health Administration Safety PDF
Copyright
Download Now -
© © All Rights Reserved
Available Formats
PDF, TXT or read online from Scribd
OSHA 10 CONSTRUCTION
Share this document
FINAL EXAM
1. What are two US governm ent agencies that are good resourc es for safety and health infor mation?
Facebook
B. FBI and CIA
C. IRS and SCOTUS
Twitter
D. OSHA and NIOSH (correct answer)
2. OSHA requires fall protection w hen workin g near the edge of a trench or excavation that is _________ or
more in depth.
A. 4 feet
B. 6 feet (correct answer)
Email
C. 10 feet
D. 20 feet
E. None of the above.
3. Every supported scaffold and its components must support, without failure, its own weight and at least
_______ the intended lo ad.
A. 2 times
B. 3 times
+
C. 4 times (correct answer)
D. 6 times ,
4. During an OSHA insp ection:
Learn more
5. The OSHA standards for Construct ion and General Industr y are foun d in:
8. What section of the OSH Act does the Whistleblow er Program reference?
A. Section 7(a)
B. Section 8
C. Section 11(c) (correct answer)
D. Section 21
9. OSHA requires fall protection at different heights for construction and general industry however, regardless
of the fall distance, which of th e following is mo st
A. It is determined to have strength and structural integrity to support intended loads (correct answer)
B. OSHA has visited the site and inspected the scaffold
C. The surface is completely dry
D. All of the above
11. From your choices below, what would you consider to be a "major" fall hazard in construction?
13. If there are defects found dur ing the inspectio n of personal fall protection equip ment, or if the equip ment has
been used in an arrest, it must b e:
A. Fixed on the spot and tested by twisting the fabric or rope and looking for stress
B. Turned in at the end of the shift
C. Removed immediately from service (correct answer)
D. None of the above
14. More than 33% of fatalities in construction are from a combination of falls from:
15. Examples of fall hazards that have resulted in deaths on the jobsit e include:
17. Three major compon ents of a Personal Fall Arrest System (PFAS) includ e; anchor and the anchorage
connector; full bod y harness; and:
18. When using scaffolds, make sure there is which of the following?
19. Preventing fall hazards is a critical part of the construction pl anning process. Controls to mitigate fall
hazards include installing which of the following?
A. Guardrails
B. Walls
C. Protective covers
D. Parapets
E. All of the above (correct answer)
20. OSHA requires fall protection at different heights for const ruction and general industry how ever, regardless
of the fall distance, which of th e following is mo st correct?
21. D-rings and snap-hooks must have a minimum tensile strength of:
A. 500 pounds
B. 1500 pounds
C. 5,000 pounds (correct answer)
D. 25,000 pounds
22. Horizontal lif elines shall be designed, installed, and used under the supervis ion of a _______ as part of a
complete personal fall arrest system, which maintains a safety factor of at least two.
A. Registered Engineer
B. OSHA expert
C. Qualified Person (correct answer)
D. Any of the above
( Useful
) Not Useful
23. Preventing fall hazards is a critical part of the construction pl anning process. Controls to mitigate fall
hazards include installing which of the following?
A. Guardrails
B. Walls
C. Protective covers
D. Parapets
E. All of the above (correct answer)
24. Where there is no specifi c OSHA standard, emplo yers must compl y with the OSH Act's:
A. Catch-All Standard
B. Final Notice
C. General Duty Clause (correct answer)
D. General Industry Standard
25. Typically, how lo ng does an employee have to file a complaint w ith OSHA, when the emplo yee has been
discriminated against for r eporting a safety or health hazard?
A. 3 days
B. 10 days
C. 30 days (correct answer)
D. 60 days
27. A worker or wo rker representative can file a compl aint about a safety or health hazard in the workp lace.
A. Bullets
B. Pieces
C. Slices
D. Subparts (correct answer)
31.
33. Which of the
Who does followi
OSHA ng is a type
recommend of fir
you O
A.
A. Repeat
OSHA
B.
B. Serious
The local police department
C.
C. Willful
Your employer (correct answer)
D.
D. All
Your the above (correct answer)
of lawyer
32.
34. Among th e righ tsfall
OSHA standards related tour
into fo OSHA
categr
Agri cu ltur e.
A. All first aid treatment forms
A.
B. True (correct
All workers' answer)
compensation forms
B.
C. False
Medical and exposure records for
D. OSHA 300 Logs and OSHA 300A
35. What type of OSHA inspection is co
A. Complaint
B. Imminent danger (correct answer
C. Programmed
Get All Answers t
D. Referral
Cancel Anytime
! " # $ %
Related Interests
Occupational Safety And Health Administration S
Related Searches
Osha 10 Answers Osha 10 Construction Osha
Popular in Employment
ABOUT SUPPORT
Press Accessibility
Contact Us Publishers
Join today
Invite Friends
Gi!s
LEGAL
& ! " '
Terms
Privacy
Copyright
Scribd
Copyright © 00001 .
2020 Scribd Inc. Browse Books . Site Directory .
Books, audiobooks, and more. 2
Site Language: English
Get our free app
& 3 4 5
Home Books Audiobooks Documents