Professional Documents
Culture Documents
LTE Retainability PDF
LTE Retainability PDF
Definition: Ability of a user to retain the E-RAB once Connected for the
desired duration.
4> H/W issue,Alarm issue.Correct the issue based on Problem u Identify.Take help
of Alex if you are not Understanding the Alarm meaning.
.
RetainAbility/SARR(Session abnormal release rate) :-
› From drive test analysis, it was observed that a large portion of the
drop calls were due to poor radio environment.
› Just before HO, it was observed that the UE SINR was poor and this
caused the UE to drag the call in poor radio environment rather than
HO faster to a neighbour cell with better RSRP.
› In this optimization project, 2 parameters were tuned; A3offset and
a2TresholdRsrpPrim.
– A3offset : change from 3 to 2 db
– a2TresholdRsrpPrim : change from -120 to -110 dbm
› A trial was also conducted to evaluate the impact of changing the
values below for a few sites with high DCR:
– DataRadioBearer : dlMaxRetxThreshold / ulMaxRetxThreshold
› 8 to 32
– SignalingRadioBearer : dlMaxRetxThreshold / ulMaxRetxThreshold
› 8 to 32
Retainibility/SARR(Session abnormal release rate) :-
› RL Failure Timing
– t-PollRetransmit = 45ms (SRB), 50ms (DRB)
– If retransmission limit increases from 8 32, RL failure due to
retransmission limit reached:
› SRB: 360ms (8) 1440ms (32)
› DRB: 400ms (8) 1600ms (32) Therefore, from drive test
< T310 (2000ms) analysis, it is often observed
that the drop occur before
T310 time out because ReTx
hits upper limit first
LTE Retainability Tuning
MAC_RA_Problem – Random
Access attempt to re-sync, for
no response after 10
retransmission (SIB2)
MAC_RA_Problem – Random
Access attempt to re-sync, for
no response after 10
retransmission (SIB2)
schedulingAlgorithm - qci 6
QciProfilePredefined Site Level Parameter RESOURCE_FAIR (0)
THANK YOU