Professional Documents
Culture Documents
Psp7.5.1sop (R.1) Stiching
Psp7.5.1sop (R.1) Stiching
: 0
DOC CODE: DOC. TITLE: REXINE STITCHES DATE 01.01.2020
PSP7.5.1SOP(R.1) REF. TO LEVEL II DOC. CODE: PSP7.5.1 PAGE: 1 OF 3
1.0 PURPOSE
1.1 The purpose this procedure is to define the stitching methodology for rexine materials.
2.0 SCOPE
2.1 This process is applicable to operators , supervisors of Rexine work shop in CDEL
3.0 INPUTS
4.0 PROCEDURE
4.1.1 Upon arrival of rexine sheet and the warehouse receiver and I/C shall verify colour
wear / tear , marks if any defects are present replace those materials
4.1.2 Perform the visual inspection for all received components before process the work
like rexine colour,
4.2 Equipment preparation
4.2.1 Put on all safety equipment like apron and tie back loose hair or clothing before
operating
4.2.2 Check to make sure all parts of machine are working and functioning properly
4.3 Steps involved
4.3.1 Set up work piece for sewing, make sure sewing path is clearly visible
4.3.2 Set up sewing machine with correct needle( needle size 14-16), thread( polyster No
30-40), and desired sewing pattern (pattern options located on front face of machine)
4.3.3 Instructions on threading the machine
4.3.3.1 Winding the robbine
1. Place your thread spool on the spool pin. Place your spool of thread on the top of the
sewing machine, on the spool pin.
2. Pull the thread out.
3. Thread the bobbin.
4. Put the bobbin on the bobbin pin.
5. Start the bobbin winder.
6. Finish winding the bobbin.
7. Remove the bobbin.
4.3.3.2 Threading the upper part of the machine
1. Place the thread spool onto the spool pin.
CDEL STANDARD OPERATING PROCEDURE REV. NO.: 0
DOC CODE: DOC. TITLE: REXINE STITCHES DATE 01.01.2020
PSP7.5.1SOP(R.1) REF. TO LEVEL II DOC. CODE: PSP7.5.1 PAGE: 2 OF 3
5.0 RECORDS
Sl. Doc. Code of Doc. Title of record Retained Mode of
No Format/ Checklist With For Disposal
1
6.0 AUTHENTICATION
PARTICULARS DESIGNATION SIGNATURE
PREPARED BY REXINE WORK I/C
REVIEWED AND PM&GM
APPROVED BY
ISSUE AND QMS COORDINATOR
CONTROL BY