Professional Documents
Culture Documents
Aa 7075 6001 PDF
Aa 7075 6001 PDF
RAW MATERIAL DATA SHEET FOR STEEL INGOTS / CC BLOOMS / ROLLED BILLETS
RMDS No. 6001 Revision 0 Date 2-Dec-19
Grade AA 7075 Size As per enquiry / Purchase order
CHEMICAL COMPOSITION:
Fe% % Mn % Si Mg% Zn% Ti% Cr% % Cu Other Elements, each
0.20 Max 0.10Max 0.15Max 2.1 - 2.9 5.1 - 6.1 0.10Max 0.18-0.28 1.2-2.0 0.05 Max
Ca% Na% 0.15Max .- .- .- .- .- .-
0.001 0.0005 0.001 .- .- .- .- .- .-
Gaseous contents in ppm Special requirements
N2 NA 1. Other Elements, total 0.15 Max
2.Variation in chemical composition between top and bottom portion sgould be minimum
O2 NA
H2 0.15ml/100g of molten metal Aluminium(Al) : Balance
NOTES:
3) Grain size should be uniform and average grain size shall be 150 Microns without any coring and cell size of 70 m Max
4)Billet shall pass Ultrasonic testing according to class A1 of AMS 2630 D (1.2mm FBH for Single point discontuinity and
0.8mm FBH for multiple discontinuity).
5) Macrostructure, shall pass mactro test according to ATM E 340, free from discontinuties & porosities etc
INSTRUCTION TO SUPPLIER:
1) The surface should be free of defects such as cracks, laps, seams, porosities & laminations etc.
2) Report the microstructure and Grain size after Homogenisation and free from coring along with TC.
Note: In case grain size and imicrostrucutre are not met after further processing at MFPL., the heat will be rejected.
Test certificate must include: a) melting & Casting route b) Chemical composition & Gas content
c) Weight d) Certification of supply condition f) Grain Size and Microstrucutre g) RMDS No., P.O. No. & Date
* RESIDUAL ELEMENTS NOT TO BE ADDED INTENTIONALLY, TO BE KEPT MIN AS POSSIBLE. VALUES TO BE ANALYSED &
REPORTED IN TC.
Prepared by Reviewed & Approved by
(Maneesh Rathee) (K.Ganapathy)